非均质多层储层中CO2驱替方式对驱油效果及储层伤害的影响

doi:10.7623/syxb202007009

石油学报 ›› 2020, Vol. 41 ›› Issue (7): 875-884,902.DOI: 10.7623/syxb202007009

非均质多层储层中CO₂驱替方式对驱油效果及储层伤害的影响

王千¹, 杨胜来¹, 拜杰², 钱坤¹, 李佳峻¹

1. 中国石油大学(北京)石油工程学院北京 102249;
2. 中国石油长庆油田公司油气工艺研究院陕西西安 710021

收稿日期:2019-07-25 修回日期:2020-04-27 出版日期:2020-07-25 发布日期:2020-08-08
通讯作者: 杨胜来,男,1961年10月生,1982年获太原理工大学学士学位,1996年获中国矿业大学博士学位,现为中国石油大学(北京)石油工程学院教授,主要从事油气田开发工程方向研究工作。Email:yangsl@cup.edu.cn
作者简介:王千,男,1991年1月生,2014年获西南石油大学学士学位,现为中国石油大学(北京)博士研究生,主要从事油气田开发方向的研究。Email:wq5635137@163.com
基金资助:
国家自然科学基金项目"超深层碎屑岩油气藏渗流物理基础研究"（No.51774300）和国家科技重大专项"CO₂驱油与埋存关键技术"（2016ZX05016-006-004）资助。

Influence of CO₂ flooding mode on oil displacement effect and reservoir damage in heterogeneous multi-layer reservoirs

Wang Qian¹, Yang Shenglai¹, Bai Jie², Qian Kun¹, Li Jiajun¹

1. College of Petroleum Engineering, China University of Petroleum, Beijing 102249, China;(;
2. Research Institute of Oil/Gas Technology, PetroChina Changqing Oilfield Company, Shaanxi Xi'an 710021, China

Received:2019-07-25 Revised:2020-04-27 Online:2020-07-25 Published:2020-08-08

摘要/Abstract

摘要：

低渗透油藏注CO₂开发过程中沥青质沉淀和CO₂—地层水—岩石相互作用引起的储层堵塞加剧了非均质多层砂岩储层中驱替特征的复杂性，影响CO₂和CO₂-水交替驱（CO₂-WAG）驱油过程中流体在储层中的渗流和最终的原油采收率。研究中的CO₂和CO₂-WAG驱油实验是在混相条件下（70℃、18 MPa）模拟的具有相似物性的多层储层系统中进行的，从油气产量、剩余油分布和渗透率损害3方面评价了两种驱替方式。实验结果表明，CO₂驱后整个系统的采收率较低，产油主要来自高渗透层，剩余油分布在中、低渗透层。CO₂-WAG驱过程中CO₂突破时间较晚，整个系统的原油采收率显著改善。此外，CO₂驱后高渗透层的渗透率下降了16.1%，95.1%的下降幅度是由沥青质沉淀引起。在CO₂-WAG驱后，各层的渗透率下降幅度分别为29.4%、16.8%和6.9%，沥青质沉淀仍是主要因素，且引起的储层堵塞更严重，但高渗透层中CO₂-地层水-岩石相互作用引起的渗透率下降不容忽视，占20.7%的因素。因此，对于具有强非均质性的多层储层，CO₂-WAG具有更好的驱油效果，但是对沥青质沉淀的预防和控制措施是必要的。

关键词: CO₂驱, CO₂-WAG驱, 剩余油分布, 渗透率下降, 沥青质沉淀, CO₂&mdash, 地层水&mdash, 岩石相互作用, 多层非均质储层

Abstract:

During the development of low-permeability reservoirs by CO₂ injection, reservoir blockage caused by asphaltene precipitation and CO₂-formation water-rock interaction exacerbates the complexity of displacement characteristics in heterogeneous multilayer sandstone reservoirs, thus affecting the seepage of fluids in reservoirs and final oil recovery during CO₂ and CO₂-WAG flooding. In this study, the CO₂ and CO₂-WAG flooding experiments were conducted in simulated multi-layer reservoir systems with similar physical properties under miscible conditions (70℃, 18 MPa). The two displacement modes were evaluated in terms of oil and gas production, remaining oil distribution and permeability damage. The experimental results show that the oil recovery of the entire system is lower after CO₂ flooding, the oil production is mainly from the high permeability layer, the remaining oil is distributed in the medium and low-permeability layers. During the CO₂-WAG flooding, the CO₂ breakthrough time was late, and the oil recovery of the entire system was significantly improved. In addition, the permeability of the high-permeability layer decreased by 16.1% after CO₂ flooding, and 95.1% of the decrease was caused by asphaltene precipitation. However, after CO₂-WAG flooding, the permeability of each layer decreased by 29.4%, 16.8%, and 6.9%, respectively. Asphaltene precipitation is still the main factor and causes even more serious reservoir blockage. Moreover, the permeability decline caused by CO₂-formation water-rock interaction in the high-permeability layer cannot be ignored, contributing 20.7% of the corresponding factors. Therefore, for multi-layer reservoirs with strong heterogeneity, CO₂-WAG flooding has better oil displacement effect, but the prevention and control measures for asphaltene precipitation are necessary.

Key words: CO₂ flooding, CO₂-WAG flooding, remaining oil distribution, permeability reduction, asphaltene precipitation, CO₂-formation water-rock interaction, multi-layer heterogeneous reservoir

中图分类号:

TE357

王千, 杨胜来, 拜杰, 钱坤, 李佳峻. 非均质多层储层中CO₂驱替方式对驱油效果及储层伤害的影响[J]. 石油学报, 2020, 41(7): 875-884,902.

Wang Qian, Yang Shenglai, Bai Jie, Qian Kun, Li Jiajun. Influence of CO₂ flooding mode on oil displacement effect and reservoir damage in heterogeneous multi-layer reservoirs[J]. Acta Petrolei Sinica, 2020, 41(7): 875-884,902.

参考文献

[1] 胡伟,吕成远,王锐,等.水驱转CO₂混相驱渗流机理及传质特征[J].石油学报,2018,39(2):201-207.
HU Wei,LV Chengyuan,WANG Rui,et al.Porous flow mechanisms and mass transfer characteristics of CO₂ miscible flooding after water flooding[J].Acta Petrolei Sinica,2018,39(2):201-207.
[2] 刘玉章,陈兴隆.低渗油藏CO₂驱油混相条件的探讨[J].石油勘探与开发,2010,37(4):466-470.
LIU Yuzhang,CHEN Xinglong.Miscible conditions of CO₂ flooding technology used in low permeability reserviors[J].Petroleum Exploration and Development,2010,37(4):466-470.
[3] GHEDAN S G.Global laboratory experience of CO₂-EOR flooding[R].SPE 125581,2009.
[4] AMPOMAH W,BALCH R,CATHER M,et al.Evaluation of CO₂ storage mechanisms in CO₂ enhanced oil recovery sites:application to Morrow sandstone reservoir[J].Energy & Fuels,2016,30(10):8545-8555.
[5] 胡永乐,郝明强,陈国利,等.中国CO₂驱油与埋存技术及实践[J].石油勘探与开发,2019,46(4):716-727.
HU Yongle,HAO Mingqiang,CHEN Guoli,et al.Technologies and practice of CO₂ flooding and sequestration in China[J].Petroleum Exploration and Development,2019,46(4):716-727.
[6] 钱坤,杨胜来,窦洪恩,等.注CO₂过程中流体性质变化及驱油机理实验研究[J].石油科学通报,2019,4(1):69-82.
QIAN Kun,YANG Shenglai,DOU Hong'en,et al.Interaction of the CO₂-oil system and displacement mechanisms during CO₂ flooding[J].Petroleum Science Bulletin,2019,4(1):69-82.
[7] 秦积舜,韩海水,刘晓蕾.美国CO₂驱油技术应用及启示[J].石油勘探与开发,2015,42(2):209-216.
QIN Jishun,HAN Haishui,LIU Xiaolei.Application and enlightenment of carbon dioxide flooding in the United States of America[J].Petroleum Exploration and Development,2015,42(2):209-216.
[8] 吕成远,王锐,崔茂蕾,等.高含水条件下CO₂混相驱替实验[J].石油学报,2017,38(11):1293-1298.
LV Chengyuan,WANG Rui,CUI Maolei,et al.Displacement experiment of CO₂ miscible flooding under high water condition[J].Acta Petrolei Sinica,2017,38(11):1293-1298.
[9] QIAN Kun,YANG Shenglai,DOU Hongen,et al.Experimental investigation on microscopic residual oil distribution during CO₂ Huff-and-Puff process in tight oil reservoirs[J].Energies,2018,11(10):2843.
[10] TEKLU T W,ALAMERI W,GRAVES R M,et al.Low-salinity water-alternating-CO₂ EOR[J].Journal of Petroleum Science and Engineering,2016,142:101-118.
[11] SEYYEDI M,SOHRABI M.Assessing the Feasibility of Improving the Performance of CO₂ and CO₂-WAG Injection Scenarios by CWI[J].Industrial & Engineering Chemistry Research,2018,57(34):11617-11624.
[12] 韦琦,侯吉瑞,郝宏达,等.特低渗油藏CO₂驱气窜规律研究[J].石油科学通报,2019,4(2):145-153.
WEI Qi,HOU Jirui,HAO Hongda,et al.Laboratory study of CO₂ channeling characteristics in ultra-low-permeability oil reservoirs[J].Petroleum Science Bulletin,2019,4(2):145-153.
[13] JABER A K,AWANG M B,LENN C P.Box-Behnken design for assessment proxy model of miscible CO₂-WAG in heterogeneous clastic reservoir[J].Journal of Natural Gas Science and Engineering,2017,40:236-248.
[14] 唐梅荣,张同伍,白晓虎,等.孔喉结构对CO₂驱储层伤害程度的影响[J].岩性油气藏,2019,31(3):113-119.
TANG Meirong,ZHANG Tongwu,BAI Xiaohu,et al.Influence of pore throat structure on reservoir damage with CO₂ flooding[J].Lithologic Reservoirs,2019,31(3):113-119.
[15] HAN Jinju,LEE M,LEE W,et al.Effect of gravity segregation on CO₂ sequestration and oil production during CO₂ flooding[J].Applied Energy,2016,161:85-91.
[16] HAMIDI H,HADDAD A S,MOHAMMADIAN E,et al.Ultrasound-assisted CO₂ flooding to improve oil recovery[J].Ultrasonics Sonochemistry,2017,35:243-250.
[17] LEI Hao,YANG Shenglai,ZU Lihua,et al.Oil recovery performance and CO₂ storage potential of CO₂ water-alternating-gas injection after continuous CO₂ injection in a multilayer formation[J].Energy & Fuels,2016,30(11):8922-8931.
[18] 崔明明,李进步,王宗秀,等.辫状河三角洲前缘致密砂岩储层特征及优质储层控制因素——以苏里格气田西南部石盒子组8段为例[J].石油学报,2019,40(3):279-294.
CUI Mingming,LI Jinbu,WANG Zongxiu,et al.Characteristics of tight sand reservoir and controlling factors of high-quality reservoir at braided delta front:a case study from Member 8 of Shihezi Formation in southwestern Sulige gas field[J].Acta Petrolei Sinica,2019,40(3):279-294.
[19] 王琛,李天太,高辉,等.CO₂-地层水-岩石相互作用对特低渗透砂岩孔喉伤害程度定量评价[J].西安石油大学学报:自然科学版,2017,32(6):66-72.
WANG Chen,LI Tiantai,GAO Hui,et al.Quantitative study on the damage degree of CO₂-formation water-rock interaction on pore and throat of ultra-low permeability sandstone[J].Journal of Xi'an Shiyou University:Natural Science Edition,2017,32(6):66-72.
[20] 王琛,李天太,高辉,等.CO₂驱沥青质沉积对岩心的微观伤害机理[J].新疆石油地质,2017,38(5):602-606.
WANG Chen,LI Tiantai,GAO Hui,et al.Microscopic damage mechanism of Asphaltene deposition on cores during CO₂ flooding[J].Xinjiang Petroleum Geology,2017,38(5):602-606.
[21] 黄磊,沈平平,贾英,等.CO₂注入过程中沥青质沉淀预测[J].石油勘探与开发,2010,37(3):349-353.
HUANG Lei,SHEN Pingping,JIA Ying,et al.Prediction of asphaltene precipitation during CO₂ injection[J].Petroleum Exploration and Development,2010,37(3):349-353.
[22] QIAN Kun,YANG Shenglai,DOU Hong'en,et al.Formation damage due to asphaltene precipitation during CO₂ flooding processes with NMR technique[J].Oil & Gas Science and Technology-Revue d'IFP Energies Nouvelles,2019,74:11.
[23] BIKKINA P,WAN Jiamin,KIM Y,et al.Influence of wettability and permeability heterogeneity on miscible CO₂ flooding efficiency[J].Fuel,2016,166:219-226.
[24] WANG Qian,YANG Shenglai,HAN Haishui,et al.Experimental investigation on the effects of CO₂ displacement methods on Petrophysical property changes of ultra-low permeability sandstone reservoirs near injection wells[J].Energies,2019,12(2):327.
[25] SAEEDI A,DELLE PIANE C,ESTEBAN L,et al.Flood characteristic and fluid rock interactions of a supercritical CO₂,brine,rock system:south West Hub,Western Australia[J].International Journal of Greenhouse Gas Control,2016,54:309-321.
[26] US-ASTM.Standard test method for characteristic groups in rubber extender and processing oils and other petroleum-derived oils by the clay-gel absorption chromatographic method:ASTM D2007-2003[S].West Conshohocken,PA:ASTM International,2003.
[27] WANG Zhilin,YANG Shenglai,LEI Hao,et al.Oil recovery performance and permeability reduction mechanisms in miscible CO₂ Water -Alternative-Gas (WAG)injection after continuous CO₂ injection:an experimental investigation and modeling approach[J].Journal of Petroleum Science and Engineering,2017,150:376-385.
[28] HU Yufeng,LI Shi,LIU Ning,et al.Measurement and corresponding states modeling of asphaltene precipitation in Jilin reservoir oils[J].Journal of Petroleum Science and Engineering,2004,41(1/3):169-182.
[29] 房涛,张立宽,刘乃贵,等.核磁共振技术定量表征致密砂岩气储层孔隙结构——以临清坳陷东部石炭系-二叠系致密砂岩储层为例[J].石油学报,2017,38(8):902-915.
FANG Tao,ZHANG Likuan,LIU Naigui,et al.Quantitative characterization of pore structure of tight gas sandstone reservoirs by NMR T₂ spectrum technology:a case study of Carboniferous-Permian tight sandstone reservoir in Linqing Depression[J].Acta Petrolei Sinica,2017,38(8):902-915.
[30] 李潮流,胡法龙,袁超,等.利用核磁共振与常规测井联合反演确定致密储层多矿物组分[J].石油学报,2018,39(9):1019-1027.
LI Chaoliu,HU Falong,YUAN Chao,et al.Multi-mineral components of tight reservoirs determined by joint inversion of nuclear magnetic resonance and conventional logs[J].Acta Petrolei Sinica,2018,39(9):1019-1027.
[31] 黄兴,李天太,王香增,等.致密砂岩储层可动流体分布特征及影响因素——以鄂尔多斯盆地姬塬油田延长组长8油层组为例[J].石油学报,2019,40(5):557-567.
HUANG Xing,LI Tiantai,WANG Xiangzeng,et al.Distribution characteristics and its influence factors of movable fluid in tight sandstone reservoir:a case study from Chang-8 oil layer of Yanchang Formation in Jiyuan oilfield,Ordos Basin[J].Acta Petrolei Sinica,2019,40(5):557-567.
[32] ABEDINI A,TORABI F.Oil recovery performance of immiscible and miscible CO₂ huff-and-puff processes[J].Energy & Fuels,2014,28(2):774-784.
[33] ALHAMDAN M R,CINAR Y,SUICMEZ V S,et al.Experimental and numerical study of compositional two-phase displacements in layered porous media[J].Journal of Petroleum Science and Engineering,2012,98-99:107-121.
[34] LEI Hao,YANG Shenglai,QIAN Kun,et al.Experimental investigation and application of the asphaltene precipitation envelope[J].Energy & Fuels,2015,29(11):6920-6927.
[35] UETANI T.Wettability alteration by asphaltene deposition:a field example[R].SPE 171788,2014.
[36] OKWEN R T.Formation damage by CO₂ Asphaltene precipitation[R].SPE 98180,2006.
[37] 朱子涵,李明远,林梅钦,等.储层中CO₂-水-岩石相互作用研究进展[J].矿物岩石地球化学通报,2011,30(1):104-112.
ZHU Zihan,LI Mingyuan,LIN Meiqin,et al.Review of the CO₂-water-rock interaction in reservoir[J].Bulletin of Mineralogy,Petrology and Geochemistry,2011,30(1):104-112.
[38] MENDOZA DE LA CRUZ J L,ARGVELLES-VIVAS F J,MATÍAS-PÍREZ V,et al.Asphaltene-induced precipitation and deposition during pressure depletion on a porous medium:an experimental investigation and modeling approach[J].Energy & Fuels, 2009,23(11):5611-5625.
[39] MONTEAGUDO J E P,RAJAGOPAL K,LAGE P L C.Simulating oil flow in porous media under asphaltene deposition[J].Chemical Engineering Science,2002,57(3):323-337.
[40] 余义常,徐怀民,高兴军,等.海相碎屑岩储层不同尺度微观剩余油分布及赋存状态——以哈得逊油田东河砂岩为例[J].石油学报,2018,39(12):1397-1409.
YU Yichang,XU Huaimin,GAO Xingjun,et al.Distribution and occurrence status of microscopic remaining oil at different scales in marine clastic reservoirs:a case study of Donghe sandstone in Hadeson oilfield[J]. Acta Petrolei Sinica,2018,39(12):1397-1409.

非均质多层储层中CO₂驱替方式对驱油效果及储层伤害的影响

Influence of CO₂ flooding mode on oil displacement effect and reservoir damage in heterogeneous multi-layer reservoirs

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王千, 杨胜来, 拜杰, 赵卫, 李佳峻, 陈浩. CO₂驱油过程中孔喉结构对储层岩石物性变化的影响[J]. 石油学报, 2021, 42(5): 654-668,685.
[2]	邹才能, 何东博, 贾成业, 熊波, 赵群, 潘松圻. 世界能源转型内涵、路径及其对碳中和的意义[J]. 石油学报, 2021, 42(2): 233-247.
[3]	黄兴, 倪军, 李响, 薛俊杰, 柏明星, 周彤. 致密油藏不同微观孔隙结构储层CO₂驱动用特征及影响因素[J]. 石油学报, 2020, 41(7): 853-864.
[4]	吕成远, 王锐, 崔茂蕾, 唐永强, 周霞. 高含水条件下CO₂混相驱替实验[J]. 石油学报, 2017, 38(11): 1293-1298.
[5]	周宇, 王锐, 苟斐斐, 郎东江. 高含水油藏CO₂驱油机理[J]. 石油学报, 2016, 37(S1): 143-150.
[6]	谭锋奇, 许长福, 王晓光, 陈玉琨, 程宏杰, 张记刚, 彭寿昌. 砾岩油藏水驱与聚合物驱微观渗流机理差异[J]. 石油学报, 2016, 37(11): 1414-1427.
[7]	王敬刘慧卿汪超锋庞海洋. 聚合物驱数学模型的若干问题[J]. 石油学报, 2011, 32(5): 857-861.
[8]	汤勇杜志敏孙雷刘伟陈祖华. CO₂在地层水中溶解对驱油过程的影响[J]. 石油学报, 2011, 32(2): 311-314.
[9]	杨永飞姚军 M.I.J.van Dijke. 油藏岩石润湿性对气驱剩余油微观分布的影响机制[J]. 石油学报, 2010, 31(3): 467-470.
[10]	侯健杜庆军束青林张本华高达. 聚合物驱宏观剩余油受效机制及分布规律[J]. 石油学报, 2010, 31(1): 96-99.
[11]	苏云河杜志敏陈小凡宋海敬汤勇. 高含水油藏动态局部网格加密技术[J]. 石油学报, 2010, 31(1): 84-86.
[12]	白振强, 王清华, 杜庆龙, 郝兰英, 张善严, 朱伟, 于德水, 王贺军. 曲流河砂体三维构型地质建模及数值模拟研究[J]. 石油学报, 2009, 30(6): 898-902,907.
[13]	曹剑, 胡文瑄, 姚素平, 张义杰, 王绪龙, 张越迁, 唐勇, 石新璞. 准噶尔盆地储层中的锰元素及其原油运移示踪作用[J]. 石油学报, 2009, 30(5): 705-710.
[14]	黄志洁, 张一伟, 熊琦华, 王密计, 马焕英. 油藏相控剩余油分布四维模型的建立方法[J]. 石油学报, 2008, 29(4): 562-566.
[15]	刘尚奇, 杨双虎, 高永荣, 沈德煌, 鲍君刚. CO₂辅助直井与水平井组合蒸汽驱技术研究[J]. 石油学报, 2008, 29(3): 414-417,412.