石油学报 ›› 2005, Vol. 26 ›› Issue (4): 102-105.DOI: 10.7623/syxb200504022

• 石油工程 • 上一篇    下一篇

油气井工作液成本控制优化模型

郑力会, 鄢捷年, 陈勉, 张广清   

  1. 中国石油大学石油天然气工程学院 北京 102249
  • 收稿日期:2004-11-03 修回日期:2005-01-17 出版日期:2005-07-25 发布日期:2010-05-21
  • 作者简介:郑力会,男,1968年1月生,1991年毕业于江汉石油学院开发系,现为中国石油大学(北京)高级工程师,主要从事井壁稳定技术的研究和应用.E-mail:zhenglihui@sohu.com
  • 基金资助:
    国家自然科学基金项目(NO.50304010)“复杂深井井壁稳定钻前预测研究”部分内容.

Optimization model for cost control of working fluids in oil and gas wells

ZHENG Li-hui, YAN Jie-nian, Chen Mian, ZHANG Guang-qing   

  1. Faculty of Petroleum Engineering, China University of Petroleum, Beijing 102249, China
  • Received:2004-11-03 Revised:2005-01-17 Online:2005-07-25 Published:2010-05-21

摘要: 为了控制油气井工作液成本,可采用低价格的处理剂.但为了达到工作液的性能要求,其处理剂加量较大,因而其成本降低不明显.根据油气井工作液部分处理剂具有多种功能这一特性,在室内测定了采用两种处理剂时的加入量与油气井工作液性能的实验数据,根据数据分布为二次曲面的特点,运用非线性多元最小二乘法及优化理论,建立了试验数据数学关系式和优化模型.利用编制的相应应用程序,可计算出达到应用者期望的油气井工作液性能时处理剂的最少加量和对应的工作液单位成本.经多次现场应用,这种控制成本的新方法,经济效益显著.

关键词: 油气井, 工作液, 成本控制, 非线性多元最小二乘法, 优化模型, 经济效益

Abstract: In order to reduce the cost of working fluids in oil and gas wells,the lower-price agents can be used to treat wells.For the performance demand,more agents need be added into wells,and so the effect of reduced cost is unobvious.It is preferable to utilize mathematical model to reduce cost of working fluids,according to the property of multiple functions for some agents.Experimental data of the properties of working fluids and concentrations of two agents were obtained.The mathematical formulas of tested data and optimization models were established with the non-linear least-square method.The corresponding application software was developed and used to determine the optimal cost and adding amount of those agents with the expected properties.The application cases show that the new cost control method is successful for reducing cost of working fluids in oil and gas wells.

Key words: oil and gas wells, working fluids, cost control, non-linear least-square method, optimization model, economic benefit

中图分类号: