石油学报 ›› 2007, Vol. 28 ›› Issue (5): 149-152.DOI: 10.7623/syxb200705029

• 石油工程 • 上一篇    

成品油管道与热原油管道同沟敷设技术研究

宇波, 凌霄, 张劲军, 王艺   

  1. 中国石油大学石油天然气工程学院城市油气输配技术重点实验室 北京102249
  • 收稿日期:2006-11-12 修回日期:2007-03-02 出版日期:2007-09-25 发布日期:2010-08-06
  • 作者简介:宇波,男,1972年8月生,1999年获西安交通大学博士学位,现为中国石油大学(北京)油气储运工程系教授,主要从事长距离原油输送工艺、添加剂湍流减阻、强化传热、CFD/NHT数值计算方法等方面的研究.E-mail:yubobox@cup.edu.cn
  • 基金资助:
    国家自然科学基金项目(No.50506017);国家高技术研究发展计划项目(2006AA09Z357);中国石油天然气股份有限公司科技风险创新研究项目联合资助

Study on laying technology of products pipeline along with hot crude pipeline in one ditch

Yu Bo, Ling Xiao, Zhang Jinjun, Wang Yi   

  1. Key Laboratory for Urban Oil and Gas Distribution Technology, College of Petroleum Engineering, China University of Petroleum, Beijing 102249, China
  • Received:2006-11-12 Revised:2007-03-02 Online:2007-09-25 Published:2010-08-06

摘要: 同沟敷设管道中成品油管道和原油管道间的传热对原油管道的运行有一定的影响。采用非结构化有限容积法,对成品油和原油管道内复杂的流动和传热问题进行了数值模拟。为了确定同沟敷设成品油管道对原油管道的影响,对相同条件下单独敷设的原油管道进行了水力和热力计算,并与同沟敷设管道的计算结果进行了对比。结果表明,两条管道的间距取1.2m时,原油管道沿线温度受成品油管道的影响较小。

关键词: 原油管道, 成品油管道, 同沟敷设技术, 流动-传热耦合, 非结构化有限容积法, 数值模拟

Abstract: The heat transmission of products pipeline along with hot crude pipeline in one ditch has some effects on the operation of crude oil pipeline.The unstructured-finite-volume method was used to investigate the complex flow and heat transfer state in the products pipeline and hot crude pipeline laying in one ditch by numerical simulation.The hydraulic and thermal calculations of single crude pipeline and two pipelines for products and crude oil under the same condition were carried out.The result shows that the temperature of crude oil in the pipeline is almost unaffected by the products pipeline,when the interval between two pipelines was 1.2 meters.

Key words: oil pipeline, products pipeline, Laying technology of two pipelines in one ditch, flow and heat transfer interaction, unstructured-finite-volume method, numerical simulation

中图分类号: