单相水流诱发裂缝内煤粉启动机理与防控对策

doi:10.7623/syxb201708009

石油学报 ›› 2017, Vol. 38 ›› Issue (8): 947-954.DOI: 10.7623/syxb201708009

单相水流诱发裂缝内煤粉启动机理与防控对策

皇凡生, 康毅力, 李相臣, 游利军, 许成元

西南石油大学油气藏地质及开发工程国家重点实验室四川成都 610500

收稿日期:2016-12-07 修回日期:2017-06-10 出版日期:2017-08-25 发布日期:2017-09-02
通讯作者: 康毅力,男,1964年2月生,1986年获大庆石油学院学士学位,1998年获西南石油学院博士学位,现为西南石油大学教授、博士生导师,主要从事油气田开发地质学、储层保护理论与技术、非常规天然气开发研究。Email:cwctkyl@163.com
作者简介:皇凡生,男,1988年1月生,2011年获西南石油大学学士学位,现为西南石油大学博士研究生,主要从事储层保护理论与技术、煤粉形成与运移机理等方面的研究。Email:hffs2008@vip.qq.com
基金资助:
国家自然科学基金项目（No.51674209）、国家自然科学基金青年科学基金项目（No.51604236）和非常规油气层保护四川省青年科技创新研究团队项目（2016TD016）资助。

Incipient motion mechanisms and control measures of coal fines during single-phase water flow in coalbed fractures

Huang Fansheng, Kang Yili, Li Xiangchen, You Lijun, Xu Chengyuan

State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Southwest Petroleum University, Sichuan Chengdu 610500, China

Received:2016-12-07 Revised:2017-06-10 Online:2017-08-25 Published:2017-09-02

摘要/Abstract

摘要：

煤层气井排水阶段是产煤粉的关键时期，煤粉运移不但会降低煤层渗透率，而且还会堵塞井筒和损坏设备。基于水动力学原理、扩展DLVO理论和JKR接触理论，开展了单相水流阶段裂缝面黏附煤粉的受力分析，建立了以"压力梯度"为判决条件的煤粉启动力学模型，分析了颗粒尺寸、颗粒类型、裂缝缝宽和离子强度对煤粉启动的影响，并围绕"适度出煤粉"和"阻止煤粉运移"两大思路提出了相应的防控对策。结果表明：煤粉启动压力梯度随着粒径的增加，先减小、后增大；裂缝缝宽越大，煤粉启动压力梯度越小；在不利化学黏附条件下有机质颗粒的启动压力梯度小于黏土矿物微粒，但在有利条件下却大于黏土矿物微粒；有利条件下的煤粉启动压力梯度远大于不利条件下的启动压力梯度。基于"适度出煤粉理论"设计煤层合理压力梯度区间时，应以优先改善最大缝宽裂缝的渗透性为原则，向煤层中注入煤粉稳定剂可提高煤粉-裂缝面间的黏附力，从而有效阻止煤粉运移。

关键词: 煤层气井, 煤粉, 单相水流, 启动条件, 适度出煤粉, 煤粉稳定剂

Abstract:

The dewatering phase of coalbed methane (CBM) well is the critical period for coal fines production. Coal fines migration can not only reduce the coalbed permeability, but also block the shaft and break down devices. Based on hydrodynamics, extended-DLVO theory and JKR contact theory, force analysis was carried out on the coal fines attached to fracture surface at the single-phase water flow stage. A mechanical model for incipient motion of coal fines were established with "pressure gradient" as the judgment criterion, so as to analyze the influences of fines size, fines type, fracture aperture and ionic strength on incipient motion of coal fines. Additionally, corresponding control measures were proposed aiming at "proper coal fines discharge" and "the inhibition of coal fines migration". The results show that the critical pressure gradient (CPG) for incipient motion of coal fines first decreases and then increases with fines size; the larger the fracture aperture is, the less the CPG for incipient motion of coal fines will be; the CPG for incipient motion of organic fines is less than that for mineral fines under unfavorable conditions, whereas it is greater than that for mineral fines under favorable conditions; the CPG for incipient motion of coal fines under favorable conditions is rather greater than that under unfavorable conditions. When setting a reasonable range of coalbed pressure gradient using the theory of "proper coal fines discharge", to preferentially improve the permeability of the fracture with maximum aperture is taken as a principle. On the other hand, the injection of coal fines stabilizer to coalbed can increase the adhesive force between coal fines and fracture surface to prevent coal fines migration effectively.

Key words: coalbed methane well, coal fines, single-phase water flow, incipient motion condition, proper coal fines discharge, coal fines stabilizer

中图分类号:

TE357.1

皇凡生, 康毅力, 李相臣, 游利军, 许成元. 单相水流诱发裂缝内煤粉启动机理与防控对策[J]. 石油学报, 2017, 38(8): 947-954.

Huang Fansheng, Kang Yili, Li Xiangchen, You Lijun, Xu Chengyuan. Incipient motion mechanisms and control measures of coal fines during single-phase water flow in coalbed fractures[J]. Acta Petrolei Sinica, 2017, 38(8): 947-954.

参考文献

[1] 王怀勐,朱炎铭,李伍,等. 煤层气赋存的两大地质控制因素[J].煤炭学报,2011,36(7):1129-1134.
WANG Huaimeng,ZHU Yanming,LI Wu,et al.Two major geological control factors of occurrence characteristics of CBM[J].Journal of China Coal Society,2011,36(7):1129-1134.
[2] 李相臣,康毅力,周来诚,等.水饱和煤岩储层甲烷运移动态特征[J].石油学报,2015,36(7):876-881.
LI Xiangchen,KANG Yili,ZHOU Laicheng,et al.Dynamic characteristics of methane transport in water saturated coal[J].Acta Petrolei Sinica,2015,36(7):876-881.
[3] 吴国干,方辉,韩征,等."十二五"中国油气储量增长特点及"十三五"储量增长展望[J].石油学报,2016,37(9):1145-1151.
WU Guogan,FANG Hui,HAN Zheng,et al.Growth features of measured oil initially in place & gas initially in place during the 12th Five-Year Plan and its outlook for the 13th Five-Year Plan in China[J].Acta Petrolei Sinica,2016,37(9):1145-1151.
[4] 陈振宏,王一兵,孙平.煤粉产出对高煤阶煤层气井产能的影响及其控制[J].煤炭学报,2009,34(2):229-232.
CHEN Zhenhong,WANG Yibing,SUN Ping.Destructive influences and effectively treatments of coal powder to high rank coalbed methane production[J].Journal of China Coal Society,2009,34(2):229-232.
[5] 綦耀光,张芬娜,刘冰,等.煤层气井产气通道内煤粉运动特征分析[J].煤炭学报,2013,38(9):1627-1633.
QI Yaoguang,ZHANG Fenna,LIU Bing,et al.Calculation on discharge flow of pulverized coal in gas production channel for coalbed methane well[J].Journal of China Coal Society,2013,38(9):1627-1633.
[6] 张芬娜,綦耀光,莫日和,等.单相流煤层气井裂隙煤粉受力分析及启动条件[J].煤矿开采,2011,16(6):11-13.
ZHANG Fenna,QI Yaoguang,MO Rihe,et al.Force analysis of uniflow coal-dust in cracks of mine for CBM and starting condition[J].Coal Mining Technology,2011,16(6):11-13.
[7] 马飞英,刘全稳,王林,等.单相水流阶段煤层裂缝中沉积煤粉的起动[J].煤炭学报,2016,41(4):917-920.
MA Feiying,LIU Quanwen,WANG Lin,et al.Motion of incipient sedimental coal fines in coal seam fractures at single phase water flow stage[J].Journal of China Coal Society,2016,41(4):917-920.
[8] SEIDLE J P,JEANSONNE M W,ERICKSON D J.Application of matchstick geometry to stress dependent permeability in coals[R].SPE 24361,1992.
[9] LAUBACH S E,MARRETT R A,OLSON J E,et al.Characteristics and origins of coal cleat:a review[J].International Journal of Coal Geology,1998,35(1/4):175-207.
[10] SHARMA P,FLURY M,ZHOU Jun.Detachment of colloids from a solid surface by a moving air-water interface[J].Journal of Colloid and Interface Science,2008,326(1):143-150.
[11] GOLDMAN A J,COX R G,BRENNER H.Slow viscous motion of a sphere parallel to a plane wall-Ⅱ couette flow[J].Chemical Engineering Science,1967,22(4):653-660.
[12] O' NEILL M E.A sphere in contact with a plane wall in a slow linear shear flow[J].Chemical Engineering Science, 1968,23(11):1293-1298.
[13] SAFFMAN P G.The lift on a small sphere in a slow shear flow[J].Journal of Fluid Mechanics,1965,22(2):385-400.
[14] RABINOVICH E,KALMAN H.Incipient motion of individual particles in horizontal particle-fluid systems:B.Theoretical analysis[J].Powder Technology,2009,192(3):326-338.
[15] ISRAELACHVILI J N.Intermolecular and surface forces[M].London:Academic Press,1992.
[16] BERGENDAHL J,GRASSO D.Prediction of colloid detachment in a model porous media:thermodynamics[J].AIChE Journal,1999,45(3):475-484.
[17] VAN OSS C J,CHAUDHURY M K,GOOD R J.Interfacial Lifshitz-van der Waals and polar interactions in macroscopic systems[J].Chemical Reviews,1988,88(6):927-941.
[18] RAVEENDRAN P,AMIRTHARAJAH A.Role of short-range forces in particle detachment during filter backwashing[J].Journal of Environmental Engineering,1995,121(12):860-868.
[19] HOGG R,HEALY T W,FUERSTENAU D W.Mutual coagulation of colloidal dispersions[J].Transactions of the Faraday Society,1966,62:1638-1651.
[20] RUCKENSTEIN E,PRIEVE D C.Adsorption and desorption of particles and their chromatographic separation[J].AIChE Journal,1976,22(2):276-283.
[21] 张明青,刘炯天,王永田.水质硬度对煤泥水中煤和高岭石颗粒分散行为的影响[J].煤炭学报,2008,33(9):1058-1062.
ZHANG Mingqing,LIU Jiongtian,WANG Yongtian.Effects of water hardness on the dispersion of fine coal and kaolinite in coal slurry[J].Journal of China Coal Society,2008,33(9):1058-1062.
[22] BERGENDAHL J,GRASSO D.Prediction of colloid detachment in a model porous media:hydrodynamics[J].Chemical Engineering Science,2000,55(9):1523-1532.
[23] SHARMA M M,CHAMOUN H,SITA RAMA SARMA D S H,et al.Factors controlling the hydrodynamic detachment of particles from surfaces[J].Journal of Colloid and Interface Science,1992,149(1):121-134.
[24] JOHNSON K L,KENDALL K,ROBERTS A D.Surface energy and the contact of elastic solids[J].Proceedings of the Royal Society A:Mathematical,Physical and Engineering Sciences,1971,324(1558):301-313.
[25] RYAN J N,ELIMELECH M.Colloid mobilization and transport in groundwater[J].Colloids and Surfaces A:Physicochemical and Engineering Aspects,1996,107:1-56.
[26] BRADFORD S A,TORKZABAN S.Colloid transport and retention in unsaturated porous media:a review of interface-,collector-,and pore-scale processes and models[J].Vadose Zone Journal,2008,7(2):667-681.
[27] 张遂安,曹立虎,杜彩霞.煤层气井产气机理及排采控压控粉研究[J].煤炭学报,2014,39(9):1927-1931.
ZHANG Sui'an,CAO Lihu,DU Caixia.Study on CBM production mechanism and control theory of bottom-hole pressure and coal fines during CBM well production[J].Journal of China Coal Society,2014,39(9):1927-1931.
[28] 高波,康毅力,史斌,等.压裂液对煤岩气藏渗流性能的影响[J].天然气工业,2015,35(9):64-69.
GAO Bo,KANG Yili,SHI Bin,et al.Effect of fracturing fluids on the seepage properties of coalbed gas reservoirs[J].Natural Gas Industry,2015,35(9):64-69.
[29] GERCEK H.Poisson's ratio values for rocks[J].International Journal of Rock Mechanics and Mining Sciences,2007,44(1):1-13.
[30] HEDAN S,HUBERT F,PRÊT D,et al.Measurement of the elastic properties of swelling clay minerals using the digital image correlation method on a single macroscopic crystal[J].Applied Clay Science,2015,116-117:248-256.
[31] 李相臣,康毅力,尹中山.不同化学环境下煤岩表面电性与润湿性特征[J].中国矿业大学学报,2014,43(5):864-869.
LI Xiangchen,KANG Yili,YIN Zhongshan.Surface electricity and wettability of coal rock under the condition of different chemical environments[J].Journal of China University of Mining & Technology,2014,43(5):864-869.
[32] SCHEMBRE J M,KOVSCEK A R.Mechanism of formation damage at elevated temperature[J].Journal of Energy Resources Technology,2005,127(3):171-180.
[33] FRANCHI A,O'MELIA C R.Effects of natural organic matter and solution chemistry on the deposition and reentrainment of colloids in porous media[J].Environmental Science & Technology,2003,37(6):1122-1129.
[34] BROOK M S,HEBBLEWHITE B W,MITRA R.Cleat aperture-size distributions:a case study from the Late Permian Rangal coal measures,Bowen Basin,Australia[J].International Journal of Coal Geology,2016,168:186-192.
[35] 李丹琼,张士诚,张遂安,等.基于煤系渗透率各向异性测试的水平井穿层压裂效果模拟[J].石油学报,2015,36(8):988-994.
LI Danqiong,ZHANG Shicheng,ZHANG Sui'an,et al.Effect simulation of horizontal well fracturing through strata based on coal seam permeability anisotropy test[J].Acta Petrolei Sinica,2015,36(8):988-994.
[36] 刘大伟,康毅力,雷鸣,等.保护碳酸盐岩储层屏蔽暂堵技术研究进展[J].钻井液与完井液,2008,25(5):57-61.
LIU Dawei,KANG Yili,LEI Ming,et al.Research progresses in temporary plugging technology for carbonate reservoir protection[J].Drilling Fluid & Completion Fluid,2008,25(5):57-61.
[37] KAKADJIAN S,GARZA J L,ZAMORA F.Enhancing gas production in coal bed methane formations with zeta potential altering system[R].SPE 134823,2010.
[38] JAIMES M G,VALENCIA D,BAHAMON J I,et al.Modifying the zeta potential of formation fines utilizing chemical treatment:an alternative to sand control to increase productivity:a Colombian field application[R].SPE 169397,2014.
[39] NGUYEN P D,WEAVER J D,RICKMAN R D,et al.Controlling formation fines at their sources to maintain well productivity[J].SPE Production & Operations,2007,22(2):202-215.
[40] STANCIU C,VO L K,NGUYEN P D,et al.Maintaining well productivity through controlling fines migration and scale formation[R].SPE 174364,2015.
[41] ASSEF Y,ARAB D,POURAFSHARY P.Application of nanofluid to control fines migration to improve the performance of low salinity water flooding and alkaline flooding[J].Journal of Petroleum Science and Engineering,2014,124:331-340.
[42] HABIBI A,AHMADI M,POURAFSHARY P,et al.Reduction of fines migration by nanofluids injection:an experimental study[J].SPE Journal,2013,18(2):309-318.
[43] 周峰,吴杨."润滑"之新解[J].摩擦学学报,2016,36(1):132-136.
ZHOU Feng,WU Yang.A novel insight into "lubrication"[J].Tribology,2016,36(1):132-136.
[44] 刘雪芬,康毅力,罗平亚,等.氟化物对致密砂岩气体渗流能力的影响[J].石油学报,2015,36(8):995-1003.
LIU Xuefen,KANG Yili,LUO Pingya,et al.Impact of fluoride on seepage ability of tight sandstone gas[J].Acta Petrolei Sinica,2015,36(8):995-1003.

单相水流诱发裂缝内煤粉启动机理与防控对策

Incipient motion mechanisms and control measures of coal fines during single-phase water flow in coalbed fractures

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

本文评价

[1]	郭晨, 秦勇, 夏玉成, 马东民, 韩冬. 基于氢、氧同位素的煤层气合排井产出水源判识——以黔西地区比德-三塘盆地上二叠统为例[J]. 石油学报, 2017, 38(5): 493-501.
[2]	刘世奇, 赵贤正, 桑树勋, 杨延辉, 李梦溪, 胡秋嘉, 杨艳磊. 煤层气井排采液面-套压协同管控——以沁水盆地樊庄区块为例[J]. 石油学报, 2015, 36(s1): 97-108.
[3]	刘新福綦耀光刘春花李延祥赵培华. 气水两相煤层气井井底流压预测方法[J]. 石油学报, 2010, 31(6): 998-1003.