井筒内气体扩散侵入定量计算模型

doi:10.7623/syxb201709010

石油学报 ›› 2017, Vol. 38 ›› Issue (9): 1082-1090.DOI: 10.7623/syxb201709010

井筒内气体扩散侵入定量计算模型

王宁^1,2, 孙宝江¹, 刘书杰², 王志远¹, 高永海¹

1. 中国石油大学石油工程学院山东青岛 266580;
2. 中海油研究总院北京 100027

收稿日期:2017-01-19 修回日期:2017-07-29 出版日期:2017-09-25 发布日期:2017-10-09
通讯作者: 孙宝江,男,1963年11月生,1985年获华东石油学院钻井工程专业学士学位,1999年获北京大学流体力学专业博士学位,现为中国石油大学(华东)教授、博士生导师、长江学者特聘教授,主要从事油气井工程、海洋石油工程、多相流理论及应用等方面的研究。Email:Sunbj1128@126.com
作者简介:王宁,男,1988年7月生,2011年获中国石油大学(华东)石油工程专业学士学位,2017年获中国石油大学(华东)油气井工程专业博士学位,现为中海油研究总院实习生,主要从事油气井流体力学与工程研究。Email:wangninglive@hotmail.com
基金资助:
国家重点基础研究发展计划（973）项目（2015CB251200）、国家重大科技专项（2016ZX05020-006-006）、国家重点研发计划（2016YFC0303303）和教育部创新团队项目（IRT_14R58）资助。

Quantitative calculation model of diffusion gas influx in wellbore

Wang Ning^1,2, Sun Baojiang¹, Liu Shujie², Wang Zhiyuan¹, Gao Yonghai¹

1. School of Petroleum Engineering, China University of Petroleum, Shandong Qingdao 266580, China;
2. CNOOC Research Institute, Beijing 100027, China

Received:2017-01-19 Revised:2017-07-29 Online:2017-09-25 Published:2017-10-09

摘要/Abstract

摘要：

油基钻井液中更易发生气体扩散侵入，伴随油基钻井液使用的增多，有必要研究气体扩散侵入的机理并建立气体扩散侵入定量计算模型。将气体扩散侵入通道划分为气体与滤液界面、滤液滞留区、内滤饼区、外滤饼区、外滤饼区内壁与钻井液界面5个部分，在分析气体扩散侵入机理的基础上，推导了井筒内气体扩散侵入控制方程及解析解。基于解析解，给出了气体扩散侵入参量（循环工况气体侵入速率、循环工况井筒内气体总量、静止工况气体最大浓度、静止工况井筒内气体总量）的定量计算公式。结合算例分析，得到了储层长度、储层孔隙度、钻井液滤失对气体扩散侵入的影响规律。除了静止工况最大气体浓度外，气体扩散侵入参量与储层长度成线性关系。储层孔隙度的增加会促进气体的扩散侵入，但这种促进作用非常弱，低孔隙度储层和高孔隙度储层的扩散侵入参量没有数量级的差别。钻井液滤失对气体的扩散侵入具有非常明显的抑制作用，无滤失时的气体扩散侵入参量显著大于滤失时的情况。

关键词: 气侵, 扩散, 质量传递系数, 油基钻井液, 计算模型

Abstract:

Diffusion gas influx is more prone to happen in oil-based mud. Along with the increased use of oil-based mud, it is necessary to study the influx mechanism of diffusion gas influx and establish its quantitative calculation model. The diffusion gas influx channels are divided into five parts, including gas-filtrate interface, filtrate stagnant area, inner filter cake, outer filter cake, inner wall of outer filter cake and mud interface. On the basis of analyzing diffusion gas influx mechanism, the governing equation and analytical solution of diffusion gas influx in wellbore were derived. Based on analytical solution, the quantitative calculation formula of diffusion gas influx parameters (gas influx rate and gas gross in wellbore under circulated conditions as well as maximum gas concentration and gas gross in wellbore under static conditions)was established. The influence laws of reservoir length, reservoir porosity and mud leak-off on diffusion gas influx were obtained by analyzing calculation examples. In addition to maximum gas concentration under static conditions, the parameter of diffusion gas influx shows a linear relationship with reservoir length. The increase of reservoir porosity can promote diffusion gas influx, while such promotion is very weak, and there is no difference in order of magnitude between the diffusion-influx parameters of low-porosity and high-porosity reservoirs. The mud leak-off has an obvious inhibiting effect on diffusion gas influx, and the diffusion gas influx parameter under no leak-off is significantly greater than that under the opposite condition.

Key words: gas influx, diffusion, mass transfer coefficient, oil-based mud, calculation model

中图分类号:

TE312

王宁, 孙宝江, 刘书杰, 王志远, 高永海. 井筒内气体扩散侵入定量计算模型[J]. 石油学报, 2017, 38(9): 1082-1090.

Wang Ning, Sun Baojiang, Liu Shujie, Wang Zhiyuan, Gao Yonghai. Quantitative calculation model of diffusion gas influx in wellbore[J]. Acta Petrolei Sinica, 2017, 38(9): 1082-1090.

参考文献

[1] 袁智,汪海阁,葛云华,等. 含硫天然气气侵方式研究[J].石油钻采工艺,2010,32(2):46-50.
YUAN Zhi,WANG Haige,GE Yunhua,et al.Research on modes of sour natural gas cut[J].Oil Drilling & Production Technology,2010,32(2):46-50.
[2] 李相方,刚涛,隋秀香,等.欠平衡钻井期间地层流体流入规律研究[J].石油学报,2002,23(2):48-52.
LI Xiangfang,GANG Tao,SUI Xiuxiang,et al.The research of feature of formation fluid influx during underbalaced drilling[J].Acta Petrolei Sinica,2002,23(2):48-52.
[3] 任美鹏,李相方,刘书杰,等.深水钻井井筒气液两相溢流特征及其识别方法[J].工程热物理学报,2011,32(12):2068-2072.
REN Meipeng,LI Xiangfang,LIU Shujie,et al.The characteristics and identification method of gas-liquid two flow overflow in deepwater drilling[J].Journal of Engineering Thermophysics,2011,32(12):2068-2072.
[4] 孙宝江,宋荣荣,王志远.高含硫化氢天然气气侵时的溢流特性[J].中国石油大学学报:自然科学版,2012,36(1):73-79.
SUN Baojiang,SONG Rongrong,WANG Zhiyuan.Overflow behaviors of natural gas kick well with high content of H₂S gas[J].Journal of China University of Petroleum:Edition of Natural Science,2012,36(1):73-79.
[5] 徐朝阳,孟英峰,魏纳,等.气侵过程井筒压力演变规律实验和模型[J].石油学报,2015,36(1):120-126.
XU Chaoyang,MENG Yingfeng,WEI Na,et al.Experimental simulation and numerical modeling of dynamic variations in wellbore pressure during gas-kicks[J]. Acta Petrolei Sinica,2015,36(1):120-126.
[6] 石晓兵,甘一风,钟水清,等.高含硫地质环境钻井硫化氢气侵规律研究[J].石油学报,2008,29(4):601-604.
SHI Xiaobing,GAN Yifeng,ZHONG Shuiqing,et al.Study on hydrogen sulfide gas cutting in high-sulfur geological environment[J].Acta Petrolei Sinica,2008,29(4):601-604.
[7] 张兴全,周英操,刘伟,等.碳酸盐岩地层重力置换气侵特征[J].石油学报,2014,35(5):958-962.
ZHANG Xingquan,ZHOU Yingcao,LIU Wei,et al.Characters of gravity replacement gas kick in carbonate formation[J].Acta Petrolei Sinica,2014,35(5):958-962.
[8] 张兴全,周英操,刘伟,等.欠平衡气侵与重力置换气侵特征及判定方法[J].中国石油大学学报:自然科学版,2015,39(1):95-102.
ZHANG Xingquan,ZHOU Yingcao,LIU Wei,et al.A method for characterization and identification of gas kicks caused by underbalanced pressure and gravity displacement[J].Journal of China University of Petroleum:Edition of Natural Science,2015,39(1):95-102.
[9] 李之军.垂直裂缝地层气液置换及钻井液防气侵封堵技术研究[D].成都:西南石油大学,2014.
LI Zhijun.Research on gas-liquid displacement in vertical crack and drilling fluid plugging technology[D].Chengdu:Southwest Petroleum University,2014.
[10] 吴志坚,沈忠厚,李相方,等.乳化钻井液条件下高温高压气井气体扩散研究[J].天然气工业,2006,26(4):70-73.
WU Zhijian,SHEN Zhonghou,LI Xiangfang,et al.Gas diffusion in HPHT horizontal well using emulsion drilling fluid[J].Natural Gas Industry,2006,26(4):70-73.
[11] 吴志坚,沈忠厚,杨令瑞.高温高压下水平井钻井中的气体扩散研究[J].天然气工业,2006,26(11):66-69.
WU Zhijian,SHEN Zhonghou,YANG Lingrui.Research on gas diffusion during drilling in HPHT horizontal gas wells[J].Natural Gas Industry,2006,26(11):66-69.
[12] 曾义金,刘建立.深井超深井钻井技术现状和发展趋势[J].石油钻探技术,2005,33(5):1-5.
ZENG Yijin,LIU Jianli.Technical status and developmental trend of drilling techniques in deep and ultra-deep wells[J].Petroleum Drilling Techniques,2005,33(5):1-5.
[13] 张绍槐.深井、超深井和复杂结构井垂直钻井技术[J].石油钻探技术,2005,33(5):11-15.
ZHANG Shaohuai.Vertical drilling technologies in deep,ultra-deep,and complex structure wells[J].Petroleum Drilling Techniques,2005,33(5):11-15.
[14] 朱伟林.南海北部深水区油气勘探关键地质问题[J].地质学报,2009,83(8):1059-1064.
ZHU Weilin.Some key geological issues on oil and gas exploration in the northern deepwater area of the south China sea[J].Acta Geologica Sinica,2009,83(8):1059-1064.
[15] 吴时国,袁圣强.世界深水油气勘探进展与我国南海深水油气前景[J].天然气地球科学,2005,16(6):693-699.
WU Shiguo,YUAN Shengqiang.Advance of exploration and petroleum geological features of deep-water hydrocarbon in the world[J].Natural Gas Geoscience,2005,16(6):693-699.
[16] 付建红,冯剑,陈平,等.深水动态压井钻井井筒压力模拟[J].石油学报,2015,36(2):232-237.
FU Jianhong,FENG Jian,CHEN Ping,et al.Simulation on wellbore pressure during dynamic kill drilling in deep water[J].Acta Petrolei Sinica,2015,36(2):232-237.
[17] 许玉强,管志川,许传斌,等.深水钻井井筒中天然气水合物生成风险评价方法[J].石油学报,2015,36(5):633-640.
XU Yuqiang,GUAN Zhichuan,XU Chuanbin,et al.Risk evaluation methods of gas hydrate formation in the wellbore of deepwater drilling[J].Acta Petrolei Sinica,2015,36(5):633-640.
[18] 王红岩,刘玉章,董大忠,等.中国南方海相页岩气高效开发的科学问题[J].石油勘探与开发,2013,40(5):574-579.
WANG Hongyan,LIU Yuzhang,DONG Dazhong,et al.Scientific issues on effective development of marine shale gas in southern China[J].Petroleum Exploration and Development,2013,40(5):574-579.
[19] 艾军,张金成,臧艳彬,等.涪陵页岩气田钻井关键技术[J].石油钻探技术,2014,42(5):9-15.
AI Jun,ZHANG Jincheng,ZANG Yanbin,et al.The key drilling technologies in Fuling shale gas field[J].Petroleum Drilling Techniques,2014,42(5):9-15.
[20] 薛冰,张金川,唐玄,等.黔西北龙马溪组页岩微观孔隙结构及储气特征[J].石油学报,2015,36(2):138-149.
XUE Bing,ZHANG Jinchuan,TANG Xuan,et al.Characteristics of microscopic pore and gas accumulation on shale in Longmaxi Formation,northwest Guizhou[J]. Acta Petrolei Sinica,2015,36(2):138-149.
[21] 郭小哲,王晶,刘学锋.页岩气储层压裂水平井气-水两相渗流模型[J].石油学报,2016,37(9):1165-1170.
GUO Xiaozhe,WANG Jing,LIU Xuefeng.Gas-water two phase porous flow model of fractured horizontal well in shale gas reservoir[J].Acta Petrolei Sinica,2016,37(9):1165-1170.
[22] 鄢捷年,赵雄虎.高温高压下油基钻井液的流变特性[J].石油学报,2003,24(3):104-109.
YAN Jienian,ZHAO Xionghu.Rheological properties of oil-based drilling fluids at high temperature and high pressure[J].Acta Petrolei Sinica,2003,24(3):104-109.
[23] 张炜,刘振东,刘宝锋,等.油基钻井液的推广及循环利用[J].石油钻探技术,2008,36(6):34-38.
ZHANG Wei,LIU Zhendong,LIU Baofeng,et al.Popularization and recycling of oil-based drilling fluid[J].Petroleum Drilling Techniques,2008,36(6):34-38.
[24] 王显光,李雄,林永学.页岩水平井用高性能油基钻井液研究与应用[J].石油钻探技术,2013,41(2):17-22.
WANG Xianguan,LI Xiong,LIN Yongxue.Research and application of high performance oil base drilling fluid for shale horizontal wells[J].Petroleum Drilling Techniques,2013,41(2):17-22.
[25] BERTHEZENE N,DE HEMPTINNE J C,AUDIBERT A,et al.Methane solubility in synthetic oil-based drilling muds[J].Journal of Petroleum Science and Engineering,1999,23(2):71-81.
[26] RIBEIRO P R,PESSOA-FILHO P A,LOMBA R F T,et al.Measurement and modeling of methane dissolution in synthetic liquids applied to drilling fluid formulation for deep and ultradeep water wells[J].Journal of Petroleum Science and Engineering,2006,51(1/2):37-44.
[27] BIRD R B,STEWART W E,LIGHTFOOT E N.Transport Phenomena[M].2nd ed.New York:John Wiley & Sons,2001.
[28] 王宁.深水钻井气侵后环空多相流流动规律研究[D].青岛:中国石油大学,2017.
WANG Ning.Study on multiphase flow after gas kick in deep water drilling[D].Qingdao:China University of Petroleum,2017.
[29] CIVAN F,RASMUSSEN M L.Determination of gas diffusion and interface-mass transfer coefficients for quiescent reservoir liquids[J].SPE Journal,2006,11(1):71-79.

井筒内气体扩散侵入定量计算模型

Quantitative calculation model of diffusion gas influx in wellbore

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	魏兵, 尚晋, 蒲万芬, 赵金洲, Kadet Valeriy. 碳酸水-原油体系中CO₂分子的扩散行为[J]. 石油学报, 2021, 42(1): 64-72.
[2]	金衍, 韦世明, 陈康平, 夏阳. 致密气自扩散渗流模型[J]. 石油学报, 2020, 41(6): 737-744.
[3]	武宏亮, 刘鹏, 王克文, 肖承文, 冯周, 信毅, 段文星, 李雨生. 偶极横波远探测测井中反射波振幅恢复方法[J]. 石油学报, 2020, 41(4): 457-466.
[4]	任俊豪, 任晓海, 宋海强, 韩登林, 王晨晨, 盛广龙, 吕伟峰. 基于分子模拟的纳米孔内甲烷吸附与扩散特征[J]. 石油学报, 2020, 41(11): 1366-1375.
[5]	邢潇, 崔淦, 杨紫晴, 李自力. 管线钢的裂纹生长预测新模型[J]. 石油学报, 2019, 40(6): 740-747.
[6]	吴俊晨, 范宜仁, 曹军涛, 范卓颖, 王小龙, 吴飞. 基于大尺寸地层模型的砂岩储层油基钻井液侵入模拟[J]. 石油学报, 2019, 40(11): 1407-1414.
[7]	徐宝昌, 周家立, 刘伟, 付加胜. 基于数据驱动的钻井过程气侵工况预测方法[J]. 石油学报, 2019, 40(10): 1263-1269.
[8]	迟焕鹏, 单衍胜, 李奎, 胡志方, 毕彩芹. 水力喷射微小井眼水平井流动耦合模型及影响规律[J]. 石油学报, 2018, 39(8): 947-954.
[9]	胡钦红, 刘惠民, 黎茂稳, 李政, 杨锐, 张宇翔, 孙梦迪. 东营凹陷沙河街组页岩油储集层润湿性、孔隙连通性和流体—示踪剂运移[J]. 石油学报, 2018, 39(3): 278-289.
[10]	霍锦华, 张瑞, 杨磊. CTAB诱导膨润土乳液转相机理及其在可逆乳化油基钻井液中的应用[J]. 石油学报, 2018, 39(1): 122-128.
[11]	周宇, 王锐, 苟斐斐, 郎东江. 高含水油藏CO₂驱油机理[J]. 石油学报, 2016, 37(S1): 143-150.
[12]	郭小哲, 王晶, 刘学锋. 页岩气储层压裂水平井气-水两相渗流模型[J]. 石油学报, 2016, 37(9): 1165-1170.
[13]	姚振岸, 孙成禹, 石小磊, 刘牧天. 基于曲波变换和各向异性扩散滤波的联合去噪技术[J]. 石油学报, 2016, 37(4): 490-498,507.
[14]	李武广, 钟兵, 杨洪志, 杨学锋, 胡志明, 陈满. 页岩储层基质气体扩散能力评价新方法[J]. 石油学报, 2016, 37(1): 88-96.
[15]	刘康, 陈国明, 魏超南. 浮式生产系统泄漏天然气扩散规律与危险区域[J]. 石油学报, 2015, 36(8): 1018-1028.