Three principles of drill string mechanics and qualitative simulation experiments

doi:10.7623/syxb201702010

Acta Petrolei Sinica ›› 2017, Vol. 38 ›› Issue (2): 227-233.DOI: 10.7623/syxb201702010

• Petroleum Engineering • Previous Articles Next Articles

Three principles of drill string mechanics and qualitative simulation experiments

Li Zifeng, Wang Changjin, Tian Weichao, Xie Jian

Petroleum Engineering Institute of Yanshan University, Hebei Qinhuangdao 066004, China

Received:2016-09-17 Revised:2016-11-09 Online:2017-02-25 Published:2017-03-08

钻柱力学三原理及定性模拟实验

李子丰, 王长进, 田伟超, 谢健

燕山大学石油工程研究所河北秦皇岛 066004

通讯作者: 李子丰,男,1962年7月生,1983年获大庆石油学院学士学位,1992年获石油大学(北京)博士学位,现为燕山大学石油工程研究所博士生导师,主要从事油气井杆管柱力学的研究。Email:zfli@ysu.edu.cn
作者简介:李子丰,男,1962年7月生,1983年获大庆石油学院学士学位,1992年获石油大学(北京)博士学位,现为燕山大学石油工程研究所博士生导师,主要从事油气井杆管柱力学的研究。Email:zfli@ysu.edu.cn
基金资助:
国家自然科学基金项目（No.51244004，No.51374183，No.51490653）资助。

Abstract

Abstract:

In general mechanics, the system must follow the principles of equilibrium, minimum potential energy and minimum power dissipation rate; these three principles are also followed by the drill string mechanics. Any point of drill string at any time must meet the mechanical equilibrium equation. In case of multiple solutions, initial judgment is made using the principle of minimum potential energy. If multiple solutions still exist, secondary judgment is conducted using the principle of minimum power dissipation rate. The problem of drill string instability illustrates the principle of minimum power dissipation rate excludes the principle of minimum potential energy, and the former principle is unable to be adopted to replace the latter one. It has been found from the experiments that:(1) the higher the rotating speed of the rod string is, the smaller its deflection will be, and the closer to the wellbore center it will be;(2) the transition critical speed under whirling state exists. When the rotating speed is less than this critical speed, the power dissipation rate increases with the rotating speed; when the rotating speed is higher than this critical speed, the power dissipation rate first decreases rapidly and the deflection of rod string abruptly decreases, and then power dissipation rate increases;(3) the greater the viscosity of the liquid is, the smaller the transition critical speed under whirling state will be; the greater the axial load is, the smaller the transition critical speed in whirl state will be. Three principles of drill string mechanics provide a new criterion for judging the multiple solutions of complex drill string dynamics problems.

Key words: drill string mechanics, equilibrium, potential energy, dissipation, simulation experiment

摘要：

在一般力学中，系统都要遵循平衡原理、最小势能原理和最小耗散功率原理。钻柱力学也遵循这三原理。钻柱的任何一点、任何时刻，都必须满足力学平衡方程；若出现多解，先用最小势能原理判断；若还存在多解，则用最小耗散功率原理判断。用钻柱失稳问题说明了最小耗散功率原理不包含最小势能原理；不可用最小耗散功率原理取代最小势能原理。实验发现：①杆柱的转速越高，其挠度越小，越靠井筒中心。②存在涡动状态转换临界转速。当转速低于此临界转速时，随着转速的增加，耗散功率增加；当转速高于此临界转速时，随着转速的增加，耗散功率先迅速降低并且杆柱的挠度突然减小，然后随着转速的增加，耗散功率又增加。③液体的黏度越大，涡动状态转换临界转速越小；轴向载荷越大，涡动状态转换临界转速越小。钻柱力学三原理为复杂的钻柱动力学问题的多解性判别提供了新的判据。

关键词: 钻柱力学, 平衡, 势能, 耗散, 模拟实验

CLC Number:

TE21

Li Zifeng, Wang Changjin, Tian Weichao, Xie Jian. Three principles of drill string mechanics and qualitative simulation experiments[J]. Acta Petrolei Sinica, 2017, 38(2): 227-233.

李子丰, 王长进, 田伟超, 谢健. 钻柱力学三原理及定性模拟实验[J]. 石油学报, 2017, 38(2): 227-233.

References

[1] 李子丰.油气井杆管柱力学及应用[M].北京:石油工业出版社,2008:1-165.
LI Zifeng.Tubular mechanics in oil-gas wells and its applications[M].Beijing:Petroleum Industry Press,2008:1-165.
[2] 李子丰.油气井杆管柱力学研究进展与争论[J].石油学报,2016,37(4):531-556.
LI Zifeng.Research advances and debates on tubular mechanics in oil and gas wells[J].Acta Petrolei Sinica,2016,37(4):531-556.
[3] 王明杰,狄勤丰,王文昌,等.气体钻井钻柱动态应力特征[J].石油学报,2014,35(1):159-165.
WANG Mingjie,DI Qinfeng,WANG Wenchang,et al.Dynamic stress analysis of drill string in gas drilling[J].Acta Petrolei Sinica,2014,35(1):159-165.
[4] 洪迪峰,唐雪平,苏义脑,等.非连续性旋转导向钻具组合的广义纵横弯曲法[J].石油学报,2014,35(3):543-550.
HONG Difeng,TANG Xueping,SU Yinao,et al.Generalized beam-column method for non-continuous rotary steering drilling of bottom-hole assembly[J].Acta Petrolei Sinica,2014,35(3):543-550.
[5] LIAO C M,VLAJIC N,KARK H,et al.Parametric studies on drill-string motions[J].International Journal of Mechanical Sciences,2012,54(1):260-268.
[6] LIANG Erguo,LI Zifeng,HAN Yong,et al.Analysis on collapse strength of casing wear[J].Chinese Journal of Mechanical Engineering,2013,26(3):613-619.
[7] NANDAKUMAR K,WIERCIGROCH M.Stability analysis of a state dependent delayed,coupled two DOF model of drill-string vibration[J].Journal of Sound and Vibration,2013,332(10):2575-2592.
[8] CHATJIGEORGIOU I K.Numerical simulation of the chaotic lateral vibrations of long rotating beams[J].Applied Mathematics and Computation,2013,219(10):5592-5612.
[9] THOMPSON J M T,VAN DER HEIJDEN G H M.A graphical criterion for the instability of elastic equilibria under multiple loads:with applications to drill-strings[J].International Journal of Mechanical Sciences,2013,68:160-170.
[10] 李子丰.钻柱涡动理论研究的必由之路——钻井液动力润滑学与钻柱动力学相结合[J].石油学报,2013,34(3):607-610.
LI Zifeng.An inevitable way in drill-string whirling research:combination of drilling fluid power lubrication with drill string dynamics[J].Acta Petrolei Sinica,2013,34(3):607-610.
[11] 刘士光,张涛.弹塑性力学基础理论[M].武汉:华中科技大学出版社,2008:193-196.
LIU Shiguang,ZHANG Tao.Basic theory of elasticity and plasticity[M].Wuhan:Huazhong University of Science and Technology Press,2008:193-196.
[12] 魏淑强.弹性力学最小势能原理[J].清远职业技术学院学报,2008,1(2):116-117.
WEI Shuqiang.Principle of minimum potential energy in theory of elasticity[J].Journal of Qingyuan Polytechnic,2008,1(2):116-117.
[13] 杨桂通.构建和谐社会的理论基础探讨-系统辩证学原理的应用[J].系统科学学报,2008,16(1):1-8.
YANG Guitong.The theoretical foundation of harmonic society[J].Chinese Journal of Systems Science,2008,16(1):1-8.
[14] 罗迎社,唐松花,刘长文,等.关于最小耗能原理及其应用的新进展[J].铁道科学与工程学报,2009,6(2):79-86.
LUO Yingshe,TANG Songhua,LIU Changwen,et al.Advances on the least energy consumption principle and its application[J].Journal of Railway Science and Engineering,2009,6(2):79-86.
[15] 唐松花,罗迎社,周筑宝.线弹性动力学中的最小势能原理(含最小余能原理)[J].动力学与控制学报,2005,3(1):34-38.
TANG Songhua,LUO Yingshe,ZHOU Zhubao.The least potential principle and the least remaining principle in linear elastodynamics[J].Journal of Dynamics and Control,2005,3(1):34-38.
[16] 周筑宝,唐松花.功耗率最小与工程力学中的各类变分原理[M].北京:科学出版社,2007:12,29-42.
ZHOU Zhubao,TANG Songhua.Minimum power consumption rate and variational principles in engineering mechanics[M].Beijing:Science Press,2007:12,29-42.
[17] 李正军.基于最小耗能原理水力压裂裂缝启裂及扩展规律研究[D].大庆:东北石油大学,2011:26-40.
LI Zhengjun.Research on the law of fracture initiation and propagation based on principle of minimum consume energy[D].Daqing:Northeast Petroleum University,2011:26-40.
[18] 李子丰,马兴瑞,黄文虎.钻柱力学基本方程及其应用[J].力学学报,1995,27(4):406-414.
LI Zifeng,MA Xingrui,HUANG Wenhu.A general formulation of drill stem mechanics and its applications[J].Acta Mechanica Sinica,1995,27(4):406-414.
[19] LI Zifeng,LI Jingyuan.Fundamental equations for dynamic analysis of rod and pipe string in oil-gas wells and application in static buckling analysis[J].Journal of Canadian Petroleum Technology,2002,41(5):44-53.
[20] 管志川,靳彦欣,王以法.直井底部钻柱运动状态的实验研究[J].石油学报,2003,24(6):102-106.
GUAN Zhichuan,JIN Yanxin,WANG Yifa.Experimental research on motion behavior of bottom drill string in straight hole[J].Acta Petrolei Sinica,2003,24(6):102-106.

Three principles of drill string mechanics and qualitative simulation experiments

钻柱力学三原理及定性模拟实验

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Song Chuanzhen, Zhao Haining, Zhang Hui. Experiment and evaluation of extraction effect of nitrogen on light components of crude oil in Tahe oilfield [J]. Acta Petrolei Sinica, 2021, 42(3): 341-349.
[2]	Xie Jun, Li Qian, Tu Hanmin, Zhao Zihan. Special phase behavior of high water-containing tight condensate gas reservoir [J]. Acta Petrolei Sinica, 2020, 41(9): 1109-1116.
[3]	Gao Deli, Wang Yanbin. Some research progress in deepwater drilling mechanics and control technology [J]. Acta Petrolei Sinica, 2019, 40(S2): 102-115.
[4]	Qiu Zhengsong, Bao Dan, Liu Junyi, Chen Jiaxu, Zhong Hanyi, Zhao Xin, Chen Xiaohua. Microcosmic mechanism of fracture-plugging instability and experimental study on pressure bearing and tight plugging [J]. Acta Petrolei Sinica, 2018, 39(5): 587-596.
[5]	Gao Shusheng, Liu Huaxun, Ye Liyou, Hu Zhiming, An Weiguo. Physical simulation experiment and numerical inversion of the full life cycle of shale gas well [J]. Acta Petrolei Sinica, 2018, 39(4): 435-444.
[6]	Zhao Jingzhou, Li Jun, Xu Zeyang. Advances in the origin of overpressures in sedimentary basins [J]. Acta Petrolei Sinica, 2017, 38(9): 973-998.
[7]	Bao Youshu, Zhang Linye, Zhang Shouchun, Wang Yurong, Zhang Lei, Wu Lianbo, Miao Chunxin, Zhang Jin'gong. Simulation experiment and mechanism of hydrocarbon-generation retardation for source rocks [J]. Acta Petrolei Sinica, 2017, 38(7): 753-762.
[8]	Kang Hongquan, Cheng Tao, Jia Huaicun, Bai Bo, Meng Jinluo. The hydrocarbon generation characteristic of marine source rock in Meso-Cenozoic continental marginal basins [J]. Acta Petrolei Sinica, 2017, 38(6): 649-657.
[9]	Ma Zhongliang, Zheng Lunju, Xu Xuhui, Bao Fang, Yu Xiaolu. Thermal simulation experiment on the formation and evolution of organic pores in organic-rich shale [J]. Acta Petrolei Sinica, 2017, 38(1): 23-30.
[10]	Chen Cheng, Zhu Yixiang, Shi Junhui, Li Shunming, Zhang Jiajia, Wu Qiongyuan. The forming process and development pattern of shallow water delta in fault depression lacustrian basin: a case study of AG Formation in the Jake area in Fula sag, Muglad Basin, Sudan [J]. Acta Petrolei Sinica, 2016, 37(12): 1508-1517.
[11]	Di Yuan, Zhang Yuan, Wu Yu-Shu. Phase equilibrium calculation of CO₂-hydrocarbons-water system based on Gibbs free energy minimization [J]. Acta Petrolei Sinica, 2015, 36(5): 593-599.
[12]	Li Yuansheng, Li Xiangfang, Teng Sainan, Xu Darong. Phase equilibrium calculation considering the interaction between pore and molecules and the capillary pressure effect [J]. Acta Petrolei Sinica, 2015, 36(4): 511-515.
[13]	Lin Riyi, Song Duopei, Zhou Guangxiang, Wang Xinwei, Tian Xin, Yang Kai. Hydrogen sulfide formation mechanism in the process of thermal recovery [J]. ACTA PETROLEI SINICA, 2014, 35(6): 1153-1159.
[14]	Yu Wenquan, Chen Yong, Yang Ligan, Liu Xihuan, Wang Lu. Dissolution of quartz in tight sandstone reservoirs in an acidic environment [J]. ACTA PETROLEI SINICA, 2014, 35(2): 286-293.
[15]	WANG Yifeng, WANG Dongliang, MA Chenghua, LI Jian, LI Zhisheng, CHEN Jianfa, WANG Xiaobo. Mechanism of hydrocarbon expulsion from source rocks at high-over maturation stage [J]. Editorial office of ACTA PETROLEI SINICA, 2013, 34(增刊一): 51-56.