Influencing factors on coal-bed methane production of single well: A case of Fanzhuang Block in the south part of Qinshui Basin

doi:10.7623/syxb200903016

Editorial office of ACTA PETROLEI SINICA ›› 2009, Vol. 30 ›› Issue (3): 409-412.DOI: 10.7623/syxb200903016

• Oil Field Development • Previous Articles Next Articles

Influencing factors on coal-bed methane production of single well: A case of Fanzhuang Block in the south part of Qinshui Basin

CHEN Zhenhong WANG Yibing YANG Jiaosheng WANG Xianhua CHEN Yanpeng ZHAO Qingbo

Received:2008-09-18 Revised:2008-11-13 Online:2009-05-25 Published:2010-05-21
Contact: CHEN Zhenhong

影响煤层气井产量的关键因素分析——以沁水盆地南部樊庄区块为例

陈振宏王一兵杨焦生王宪花陈艳鹏赵庆波

中国石油勘探开发研究院廊坊分院河北廊坊 065007

通讯作者: 陈振宏

Abstract

Abstract:

Based on the geologic characteristics, fracturing and production technologies and accompanying performance for producing in Fanzhuang Block in the south part of Qingshui Basin, the influencing factors on coal-bed methane production of single well were analyzed. It is proved that the high-capacity well of coal-bed methane has a high ratio of critical desorption pressure to formation pressure. Great amounts of sand and fluid are required in the coal-bed methane fracturing production. Especially, there are differential flow directions of gas and water. The variable displacement fracturing technology can effectively control the fracture morphology and enhance the fracturing effect. In the process of coal-bed methane development, the appropriate producing method should be adopted with the principles of unhurried, long-term, continuous and steady. It is necessary for slowly dropping liquid level in the early production period and taking advisable casing pressure in gas production. The frequent alternation of producing measures, which would cause coal seam collapsing and blocking, should be avoided.

Key words: coal-bed methane development, capacity, desorption pressure, formation pressure, influencing factor, producing measure

摘要：

研究了沁水盆地南部樊庄区块煤层气投产井地质特征、压裂增产工艺、生产状况及排采技术等，分析了影响煤层气单井产量的关键因素，并讨论了提高煤层气井单井产量需要关注的问题。研究结果表明，煤层气高产井通常临界解吸压力与地层压力的比值较高，压裂施工时加砂量、用液量高；采用变排量施工工艺，控制裂缝形态，可提高压裂效果；特别是煤层气产出表现出“气、水差异流向”规律：构造高部位利于产气，构造低部位利于产水。在煤层气开发中，必须保证科学的排采制度，坚持“缓慢、长期、持续、稳定”的原则，排采早期保证液面稳定缓慢下降。在产气阶段，要保持合理套压，排采制度切忌变化频繁，避免由于煤层压力激动造成煤层坍塌和堵塞。

关键词: 煤层气开发, 产能, 解吸压力, 地层压力, 影响因素, 排采制度

CHEN Zhenhong WANG Yibing YANG Jiaosheng WANG Xianhua CHEN Yanpeng ZHAO Qingbo. Influencing factors on coal-bed methane production of single well: A case of Fanzhuang Block in the south part of Qinshui Basin[J]. Editorial office of ACTA PETROLEI SINICA, 2009, 30(3): 409-412.

陈振宏王一兵杨焦生王宪花陈艳鹏赵庆波. 影响煤层气井产量的关键因素分析——以沁水盆地南部樊庄区块为例[J]. 石油学报, 2009, 30(3): 409-412.

References

[1]陈振宏,宋岩.高、低煤阶煤层气藏成藏过程及优势地质模型[J].新疆石油地质,2007,26(3):275-278.
Chen Zhenhong,Song Yan.Formation processes and advantageous models for high-low-rank coalbed methane reservoirs[J].Xinjiang Petroleum Geology, 2007,26(3):275-278.
[2]王红岩,李景明,刘洪林,等.煤层气基础理论、聚集规律及开采技术方法进展[J].石油勘探与开发,2004,31(6):14-16.
Wang Hongyan,Li Jingming,Liu Honglin,et al.Progress of basic theory and accumulation law and development technology of coal-bed methane[J].Petroleum Exploration and Development,2004,31(6):14-16.
[3]Ates Y,Barron Y.Effect of gas absorption on the strength of coal[J]. Min. Sci.Tech.,1998,6(3):11-12.
[4]叶建平,史保生,张春才.中国煤储层渗透性及其主要影响因素[J].煤炭学报，1999，24（2）：118-122.
Ye Jianping,Shi Baosheng,Zhang Chuncai.Coal reservoir permeability and its controlled factors in China[J].Journal of China Coal Society,1999,24（2）：118-122.
[5]McKee C R.Using permeability vs depth correlations to assess the potential for producing gas from coal seams[J].Quarterly Review of Methane from Coal Seams Technology，1986,4（1）: 15-26.
[6]赵庆波,李五忠,孙粉锦.中国煤层气分布特征及高产富集因素[J].石油学报,1997,26(4):1-6.
Zhao Qingbo,Li Wuzhong,Sun Fenjin.Coalbed methane reservoir and gas production mechanism in anthracite coalbeds[J].Acta Petrolei Sinica,1997,26(4):1-6.
[7]饶孟余,钟建华,杨陆武,等.无烟煤煤层气成藏与产气机理研究——以沁水盆地无烟煤为例[J].石油学报,2004,29(4):23-28.
Rao Mengyu,Zhong Jianhua,Yang Luwu,et al.Coalbed methane reservoir and gas production mechanism in anthracite coalbeds[J].Acta Petrolei Sinica, 2004,29(4):23-28.
[8]陈振宏,贾承造,宋岩,等.高、低煤阶煤层气藏物性差异及其成因[J].石油学报,2008,29(2):179-184.
Chen Zhenhong,Jia Chengzao,Song Yan,et al.Differences and origin of physical properties of low-rank and high-rank coal-bed methanes[J].Acta Petrolei Sinica,2008,29(2):179-184.
[9]秦勇,宋党育,王超.山西南部晚古生代煤的煤化作用及其控气特征[J].煤炭学报,1997,22(3):230-235.
Qin Yong,Song Dangyu,Wang Chao.Coalfication of the the upper Paleozoic coal and its control to the generation and preservation of coalbed methane in the southern Shanxi[J].Journal of China Coal Society,1997,22(3):230-235.
[10]陈刚.沁水盆地燕山期构造热事件及其油气地质意义[J].西北地质科学，1997，18(2)：63-67.
Chen Gang.Tectothermal event of the Yanshannian and its significance in Qinshui Basin[J].Northwest Geoscience,1997，18(2)：63-67.
[11]张建博,王红岩,赵庆波.中国煤层气地质[M].北京：地质出版社,2000:59-62.
Zhang Jianbo,Wang Hongyan,Zhao Qingbo.Coalbed methane geology in China[M].Beijing:Geological Publishing House,2000:59-62.
[12]陈振宏.高低煤阶煤层气藏主控因素差异性对比研究[D].中国科学院,2007:19-26.
Chen Zhenhong.Key controlling factors comparison between high and low rank CBM reservoir formation[D].Chinese Academy of Sciences,2007:19-26.
[13]陈振宏,贾承造,宋岩,等.构造抬升对高、低煤阶煤层气藏储集层物性的影响[J].石油勘探与开发,2007,34(4):461-464.
Chen Zhenhong,Jia Chengzao,Song Yan,et al.Effects of tectonic uplift on physical properties of high and low rank coal reservoirs[J].Petroleum Exploration and Development,2007,34(4):461-464.
[14]Crosdale P J,Beamish B B,Valix M.Coalbed methane sorption related to coal composition[J].Int.J.Coal Geol.,1998,35:147-158.

[1]	Zhang Lei, Wang Yongke, Ni Jun, Qiao Xiangyang, Xin Cuiping, Zhang Tao, Kang Yulong, Shi Juntai, Wu Keliu. A new method for tracking and calculating average formation pressure of gas reservoirs [J]. Acta Petrolei Sinica, 2021, 42(4): 492-499,522.
[2]	Liu He, Lu Qiuyu, Zhu Shijia, Jiang Wei, Wang Suling. Application of typical clustering algorithms in analysis of system efficiency of pumping wells in blocks [J]. Acta Petrolei Sinica, 2020, 41(12): 1657-1664.
[3]	He Jing, He Sheng, Liu Zaoxue, Zhai Gangyi, Wang Yi, Han Yuanjia, Wan Kuo, Wei Sile. Pore structure and adsorption capacity of shale in the Lower Cambrian Shuijingtuo Formation in the southern flank of Huangling anticline,western Hubei [J]. Acta Petrolei Sinica, 2020, 41(1): 27-42.
[4]	Yang Jin, Huang Xin, Yang Yuxiang, Hu Zhiqiang, Song Yu, Liu Hexing, Xu Dongsheng, Cai Rao, Li Lei. Mechanical properties of a new type of expandable surface conductor in deepwater oil and gas wells [J]. Acta Petrolei Sinica, 2019, 40(S2): 116-122.
[5]	Chen Guoming, Li Jiayi, Chang Yuanjiang, Wang Kang, Xiu Zixiang, Liu Haolin, Xu Liangbin, Sheng Leixiang. Influencing factors for fatigue damage of underwater wellhead system of deepwater oil and gas [J]. Acta Petrolei Sinica, 2019, 40(S2): 141-151.
[6]	Kang Yili, Wang Kaicheng, Xu Chengyuan, You Lijun, Wang Limin, Li Ning, Li Jiaxue. High-temperature aging property evaluation of lost circulation materials in deep and ultra-deep well drilling [J]. Acta Petrolei Sinica, 2019, 40(2): 215-223.
[7]	Guo Lingyun, Zhou Jing, Dai Yunyun. Time-dependent failure probability of corroded pipelines based on different stochastic degradation processes [J]. Acta Petrolei Sinica, 2019, 40(12): 1542-1552.
[8]	Yang Jin. Calculation method of surface conductor setting depth in deepwater oil and gas wells [J]. Acta Petrolei Sinica, 2019, 40(11): 1396-1406.
[9]	Kang Yongshang, Wang Jin, Jiang Shanyu, Zhang Bing, Mao Delei, Gu Jiaoyang. Application of quantitative indexes in quantitative evaluation of coalbed methane development potential [J]. Acta Petrolei Sinica, 2017, 38(6): 677-686.
[10]	Wu Jin, Liang Feng, Lin Wen, Wang Hongyan, Bai Wenhua, Ma Chao, Sun Shasha, Zhao Qun, Song Xiaojiang, Yu Rongze. Reservoirs characteristics and gas-bearing capacity of Wufeng-Longmaxi Formation shale in Well WX-2, northeast Chongqing area [J]. Acta Petrolei Sinica, 2017, 38(5): 512-524.
[11]	Su Wei, Hou Jirui, Li Haibo, Zhao Teng, Xi Yuanyuan. Feasibility and influencing factors of nitrogen foam injection in fractured-cavity type carbonate reservoirs [J]. Acta Petrolei Sinica, 2017, 38(4): 436-443.
[12]	Zhou Mingshun, Fan Yiren, Liu Zhijie, Wu Jianfeng, Li Hui, Song Yan, Gao Yanwu. Logging prediction method for productive capacity of complex sandstone reservoirs in Raoyang sag [J]. Acta Petrolei Sinica, 2017, 38(2): 208-216.
[13]	Wang Ke, Zhang Huiliang, Zhang Ronghu, Wang Junpeng, Dai Junsheng, Yang Xuejun. Characteristics and influencing factors of ultra-deep tight sandstone reservoir structural fracture: a case study of Keshen-2 gas field, Tarim Basin [J]. Acta Petrolei Sinica, 2016, 37(6): 715-727,742.
[14]	Zhu Benrui, Chen Guoming, Lin Hong, Liu Hongbing. Dynamic pushover analysis method of deep-water jacket platform [J]. Acta Petrolei Sinica, 2016, 37(12): 1550-1556.
[15]	Liu Zhen, Sun Di, Li Weilian, Liu Mingjie, Xia Lu, Liu Jingjing. Advances in research on stratigraphic porodynamics of sedimentary basins [J]. Acta Petrolei Sinica, 2016, 37(10): 1193-1215.

Influencing factors on coal-bed methane production of single well: A case of Fanzhuang Block in the south part of Qinshui Basin

影响煤层气井产量的关键因素分析——以沁水盆地南部樊庄区块为例

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments