Constant volume depletion experiment and phase characteristics of condensate gas in dense porous media

doi:10.7623/syxb201911009

Acta Petrolei Sinica ›› 2019, Vol. 40 ›› Issue (11): 1388-1395.DOI: 10.7623/syxb201911009

• Oil Field Development • Previous Articles Next Articles

Constant volume depletion experiment and phase characteristics of condensate gas in dense porous media

Hu Wei^1,2,3, Lü Chengyuan^1,2, Lun Zengmin^1,2, Wang Rui^1,2, Yang Yang^1,2, Xiao Pufu^1,2

1. Sinopec Key Laboratory of Marine Oil&Gas Reservoirs Production, Beijing 100083, China;
2. Department of Enhanced Oil Recovery, Sinopec Petroleum Exploration and Production Research Institute, Beijing 100083, China;
3. Postdoctoral Mobile Research Station, China University of Petroleum, Beijing 102249, China

Received:2018-11-27 Revised:2019-06-10 Online:2019-11-25 Published:2019-12-07

致密多孔介质中凝析气定容衰竭实验及相态特征

胡伟^1,2,3, 吕成远^1,2, 伦增珉^1,2, 王锐^1,2, 杨阳^1,2, 肖朴夫^1,2

1. 中国石油化工集团公司海相油气藏开发重点实验室北京 100083;
2. 中国石油化工股份有限公司石油勘探开发研究院提高采收率技术研究所北京 100083;
3. 中国石油大学(北京)博士后科研流动站北京 102249

通讯作者: 胡伟,男,1988年1月生,2010年获长江大学学士学位,2016年获中国石油大学(北京)博士学位,现为中国石油化工股份有限公司石油勘探开发研究院博士后,主要从事流体相态和油气渗流理论方面研究。Email:huwei.syky@sinopec.com
作者简介:胡伟,男,1988年1月生,2010年获长江大学学士学位,2016年获中国石油大学(北京)博士学位,现为中国石油化工股份有限公司石油勘探开发研究院博士后,主要从事流体相态和油气渗流理论方面研究。Email:huwei.syky@sinopec.com
基金资助:
国家科技重大专项（2016ZX05048-003）资助。

Abstract

Abstract:

The development plan of condensate gas reservoir depletion depends on pressure-volume-temperature (PVT)phase behavior experiment, while the conventional PVT phase behavior experiment neglects the influence of porous media on the condensate gas phase behavior, resulting in deviations from the actual results. Based on the principle of constant volume depletion (CVD)experiment under a conventional PVT mode, this paper establishes a device for simulating the constant volume depletion of condensate gas in dense porous media and its experimental method; it also stimulates and studies the dynamic depletion development of condensate gas in fractured tight reservoirs, analyzes the effects of depletion rate and porous media on the condensate gas development, and clarifies the phase characteristics of condensate gas in dense porous media. The results show that the depletion rate is the main reason that affects the development of condensate gas reservoirs. The natural gas recovery factor decreases with the increase of depletion rate, but the condensate recovery factor shows the opposite. The dew point pressure of condensate gas in dense porous media is 9.42% higher than that measured in the PVT cell. In addition, the fracture can effectively increase the drainage area, reduce the seepage resistance, and improve the recovery of natural gas and condensate oil.

Key words: dense, porous media, condensate gas, phase behavior, constant volume depletion

摘要：

凝析气藏衰竭开发方案的制定依赖于PVT相态实验，而常规PVT相态实验忽略了多孔介质对凝析气相态的影响，导致实验结果与实际存在偏差。基于常规PVT定容衰竭实验原理，建立了致密多孔介质中凝析气定容衰竭模拟装置及实验方法，模拟研究了凝析气在裂缝性致密储层中的衰竭开发动态，分析了衰竭速度及多孔介质的作用对凝析气藏开发效果的影响，明确了致密多孔介质中凝析气相态特征。研究结果表明，衰竭速度是影响凝析气藏开发的主要原因，天然气采收率随衰竭速度的增快而降低，但凝析油采收率则表现出相反规律；致密多孔介质中凝析气的露点压力比PVT筒中的测量值提高9.42%。此外，裂缝能够有效增大泄油面积，减小渗流阻力，提高天然气和凝析油采收率。

关键词: 致密, 多孔介质, 凝析气, 相态, 定容衰竭

CLC Number:

TE372

Hu Wei, Lü Chengyuan, Lun Zengmin, Wang Rui, Yang Yang, Xiao Pufu. Constant volume depletion experiment and phase characteristics of condensate gas in dense porous media[J]. Acta Petrolei Sinica, 2019, 40(11): 1388-1395.

胡伟, 吕成远, 伦增珉, 王锐, 杨阳, 肖朴夫. 致密多孔介质中凝析气定容衰竭实验及相态特征[J]. 石油学报, 2019, 40(11): 1388-1395.

References

[1] THOMAS F B,BENNION D B,ANDERSEN G.Gas condensate reservoir performance[J].Journal of Canadian Petroleum Technology,2009,48(7):18-24.
[2] GUO Ping,YANG Jinhai,LI Shilun,et al.Experimental investigation of critical flow condensate saturation[R].SPE 68697,2001.
[3] VO H X,HORNE R N.Experimental study of composition variation during flow of gas-condensate[R].SPE 175011,2015.
[4] 王旭林,梁伯勋,蒲建.凝析气藏流体恒体积衰竭试验方法:中国,200610165010.6[P].2007-05-30.
WANG Xulin,LIANG Boxun,PU Jian.Constant volume depletion test method for condensate gas reservoir:China,200610165010.6[P].2007-05-30.
[5] 苏奥,陈红汉,吴悠,等.砂岩储层烃类不混溶包裹体特征、成因及地质意义[J].石油学报,2017,38(7):763-776.
SU Ao,CHEN Honghan,WU You,et al.Characteristics,genesis and geological significance of natural hydrocarbon immiscible inclusions in sandstone reservoirs[J].Acta Petrolei Sinica,2017,38(7):763-776.
[6] 童敏,李相方,胡永乐,等.多孔介质对凝析气相态的影响[J].石油大学学报:自然科学版,2004,28(5):61-64.
TONG Min,LI Xiangfang,HU Yongle,et al.Experimental study on influence of porous media on phase behavior of gas condensate[J].Journal of the University of Petroleum,China:Edition of Natural Science,2004,28(5):61-64.
[7] 李敬松,李相方,童敏,等.多孔介质中凝析气液相变实验新方法研究[J].石油勘探与开发,2004,31(6):101-103.
LI Jingsong,LI Xiangfang,TONG Min,et al.A novel experiment method on phase change of gas condensate in porous media[J].Petroleum Exploration and Development,2004,31(6):101-103.
[8] 王志伟,李相方,程时清,等.多孔介质凝析气相变的影响因素[J].天然气工业,2006,26(1):90-92.
WANG Zhiwei,LI Xiangfang,CHENG Shiqing,et al.Influential factors on phase change of condensate gas in porous media[J].Natural Gas Industry,2006,26(1):90-92.
[9] 郭平,孙良田,孙雷.多孔介质毛细管压力对凝析油气相态影响研究[J].石油勘探与开发,1994,21(4):64-69.
GUO Ping,SUN Liangtian,SUN Lei.A theoretical study of the effect of capillary pressure of porous media on the phase state of a condensate[J].Petroleum Exploration and Development,1994,21(4):64-69.
[10] 杨金海,李士伦,郭平,等.孔隙介质中气体相变超声波测试方法研究[J].西南石油学院学报,1999,21(3):22-24.
YANG Jinhai,LI Shilun,GUO Ping,et al.Ultrasonic method for detecting the phase transition of gas in porous media[J].Journal of Southwest Petroleum Institute,1999,21(3):22-24.
[11] 隋淑玲,郭平,杜建芬,等.低渗多孔介质中凝析气衰竭实验研究[J].西南石油大学学报:自然科学版,2010,32(3):97-100.
SUI Shuling,GUO Ping,DU Jianfen,et al.The experiment of gas condensate depletion in low-permeability porous medium[J].Journal of Southwest Petroleum University:Science & Technology Edition,2010,32(3):97-100.
[12] 郭平,王娟,刘伟,等.缝洞型凝析气藏衰竭开采动态实验研究[J].石油钻采工艺,2013,35(2):67-70.
GUO Ping,WANG Juan,LIU Wei,et al.Dynamic experiment study on depletion development of condensate gas reservoir with fracture and cave[J].Oil Drilling & Production Technology,2013,35(2):67-70.
[13] 赵越超,宋永臣,陈俊霖,等.多孔介质内多相多组分渗流磁共振成像检测实验系统研制[J].实验技术与管理,2015,32(6):84-89.
ZHAO Yuechao,SONG Yongchen,CHEN Junlin,et al.Practice on experimental system of multiphase multicomponent fluids flow in porous media using MRI[J].Experimental Technology and Management,2015,32(6):84-89.
[14] 赵越超,宋永臣,郝敏,等.磁共振成像在CO₂驱油实验中应用[J].大连理工大学学报,2012,52(1):23-28.
ZHAO Yuechao,SONG Yongchen,HAO Min,et al.Application of MRI to CO₂ displacement oil experiments[J].Journal of Dalian University of Technology,2012,52(1):23-28.
[15] 张国龙,何志强,朱建钧,等.凝析气藏衰竭式开发影响因素实验[J].大庆石油地质与开发,2016,35(1):62-65.
ZHANG Guolong,HE Zhiqiang,ZHU Jianjun,et al.Experiment on the influencing factors of the natural depletion development for condensate gas reservoirs[J].Petroleum Geology and Oilfield Development in Daqing,2016,35(1):62-65.
[16] MENG Xingbang,SHENG J J.Experimental study on revaporization mechanism of huff-n-puff gas injection to enhance condensate recovery in shale gas condensate reservoirs[R].SPE 179537,2016.
[17] 国家能源部.油气藏流体物性分析方法:GB/T 26981-2011[S].北京:石油工业出版社,2011.
Ministry of Energy.Test method for reservoir fluid physical properties:GB/T 26981-2011[S].Beijing:Petroleum Industry Press,2011.
[18] 刘春,张荣虎,张惠良,等.致密砂岩储层微孔隙成因类型及地质意义——以库车前陆冲断带超深层储层为例[J].石油学报,2017,38(2):150-159.
LIU Chun,ZHANG Ronghu,ZHANG Huiliang,et al.Genetic types and geological significance of micro pores in tight sandstone reservoirs:a case study of the ultra-deep reservoir in the Kuqa foreland thrust belt,NW China[J].Acta Petrolei Sinica, 2017,38(2):150-159.
[19] 赵伦,卞德智,范子菲,等.凝析气顶油藏开发过程中原油性质变化[J].石油勘探与开发,2011,38(1):74-78.
ZHAO Lun,BIAN Dezhi,FAN Zifei,et al.Oil property changes during the waterflooding for reservoirs with condensate gas cap[J].Petroleum Exploration and Development,2011,38(1):74-78.
[20] 郭平.油气藏流体相态理论与应用[M].北京:石油工业出版社,2004.
GUO Ping.Theory and application of fluid phase state in oil and gas reservoirs[M].Beijing:Petroleum Industry Press,2004.
[21] DANESH A.油藏流体的PVT与相态[M].沈平平,韩冬,译.北京:石油工业出版社,2000.
DANESH A.PVT and phase behaviour of petroleum reservoir fluids[M].SHEN Pingping,HAN Dong,trans.Beijing:Petroleum Industry Press,2000.
[22] QI Zhilin,LIANG Baosheng,DENG Ruijian,et al.Phase behavior study in the deep gas-condensate reservoir with low permeability[R].SPE 107315,2007.
[23] 胡伟,吕成远,王锐,等.水驱转CO₂混相驱渗流机理及传质特征[J].石油学报,2018,39(2):201-207.
HU Wei,LÜ Chengyuan,WANG Rui,et al.Porous flow mechanisms and mass transfer characteristics of CO₂ miscible flooding after water flooding[J].Acta Petrolei Sinica,2018,39(2):201-207.
[24] 胡伟.水驱油藏注气驱油机理及渗流规律研究[D].北京:中国石油大学(北京),2016.
HU Wei.The mechanism study of gas injection and multiple phase flow in water flooding reservor[D].Beijing:China University of Petroleum,2016.
[25] 杜建芬,李士伦,尹永飞,等.多孔介质对凝析气藏露点的影响机理研究[J].西南石油学院学报,2006,28(4):26-28.
DU Jianfen,LI Shilun,YIN Yongfei,et al.A study on the mechanics of porous medium effecting the dew point of gas condensate reservoir[J].Journal of Southwest Petroleum Institute,2006,28(4):26-28.
[26] DU Jianfen,LI Shilun,SUN Lei.Effect of porous medium adsorption on percolation law of condensate-gas mixture[R].SPE 50926,1998.
[27] 陈浩,杨胜来,于东海,等.多孔介质内流体相态特征超声波探测研究进展[J].西南石油大学学报:自然科学版,2013,35(1):67-73.
CHEN Hao,YANG Shenglai,YU Donghai,et al.Research progress of the ultrasonic detection in phase behavior of fluids in porous media[J].Journal of Southwest Petroleum University:Science & Technology Edition,2013,35(1):67-73.

Constant volume depletion experiment and phase characteristics of condensate gas in dense porous media

致密多孔介质中凝析气定容衰竭实验及相态特征

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Xie Jun, Li Qian, Tu Hanmin, Zhao Zihan. Special phase behavior of high water-containing tight condensate gas reservoir [J]. Acta Petrolei Sinica, 2020, 41(9): 1109-1116.
[2]	Zhang Lixia, Guo Chunqiu, Jiang Hao, Cao Guangqiang, Chen Pengyu. Gas in place determination by material balance-quasipressure approximation condition method [J]. Acta Petrolei Sinica, 2019, 40(3): 337-349.
[3]	Wei Na, Sun Wantong, Meng Yingfeng, Zhou Shouwei, Fu Qiang, Guo Ping, Li Qingping. Annular phase behavior analysis during marine natural gas hydrate reservoir drilling [J]. Acta Petrolei Sinica, 2017, 38(6): 710-720.
[4]	Di Qinfeng, Zhang Jingnan, Ye Feng, Wang Wenchang, Chen Huijuan, Hua Shuai. Nuclear magnetic resonance visualization experiment of gravity tongue characteristics in the displacement process [J]. Acta Petrolei Sinica, 2017, 38(10): 1183-1188.
[5]	Bi Yongqiang, Yu Li, Xiu Jianlong, Yi Lina, Huang Lixin, Wang Tianyuan. Migration and retention mechanism of microorganisms for oil recovery in porous media [J]. Acta Petrolei Sinica, 2017, 38(1): 91-98.
[6]	He Yanlong, Pu Chunsheng, Jing Cheng, Gu Xiaoyu, Liu Hongzhi, Cui Shuxia, Li Xiao, Song Junqiang. Reconstruction of clay mineral in three-dimensional porous media model based on Hoshen-Kopelman algorithm [J]. Acta Petrolei Sinica, 2016, 37(8): 1037-1046.
[7]	Wang Tianyuan, Xiu Jianlong, Huang Lixin, Bi Yongqiang, Qi Yibin, Cong Zhengmin, Yu Li. Microbial enhanced oil recovery model in porous media [J]. Acta Petrolei Sinica, 2016, 37(1): 97-105.
[8]	Huang Handong, Xiang Kun, Wang Yanchao, Zhang Sheng, Li Bingshu, Yang Yadi, Li Jinkui. Application of matching pursuit method for detection of fluid in carbonate rock: a case study from Chu-Sarysu Basin in Kazakhstan [J]. Acta Petrolei Sinica, 2015, 36(S2): 184-193.
[9]	Niu Bo, Gao Xingjun, Zhao Yingcheng, Song Baoquan, Zhang Danfeng, Deng Xiaojuan. Architecture characterization and modeling of channel bar in paleo-braided river: a case study of dense well pattern area of Sazhong in Daqing oilfield [J]. Acta Petrolei Sinica, 2015, 36(1): 89-100.
[10]	Zhu Weiyao, Xia Xiaoxue, Guo Shengxue, Li Juan, Song Zhiyong, Qu Guohui. Microscopic oil displacement mechanism of indigenous microorganisms under high-temperature and high-pressure conditions in reservoirs [J]. ACTA PETROLEI SINICA, 2014, 35(3): 528-535.
[11]	Tian Zipeng, Zhang Bin, Cui Haiqing, Zhang Shuyun. Mathematical model and numerical calculation for viscoelastic fluid flow through fractal porous media [J]. ACTA PETROLEI SINICA, 2014, 35(1): 118-122.
[12]	WANG Changquan, TANG Yong, DU Zhimin, CHEN Liang, SUN Yang, PAN Yi, SHI Lihong. Phase behaviors of condensate gas with vaporous water and liquid production characteristics in a non-equilibrium pressure drop process [J]. Editorial office of ACTA PETROLEI SINICA, 2013, 34(4): 740-746.
[13]	WU Keliu　LI Xiangfang　SHI Juntai　LI Qian　YAN Bicheng. A computational method for reservoir pressure of water-drive condensate gas reservoir [J]. Editorial office of ACTA PETROLEI SINICA, 2012, 33(2): 278-283.
[14]	GENG Jiaojiao YAN Jienian DENG Tianqing YAN Xiaolin SHU Yong. Characteristics of formation damage and protection drilling fluids for condensate gas reservoirs with low-permeability [J]. Editorial office of ACTA PETROLEI SINICA, 2011, 32(5): 893-899.
[15]	REN Shaoran, LIU Jianxin, LIU Yixing, FAN Zexia, LIU Yongjun, ZUO Jingluan, YU Hongmin. Experimental study on formation and dissociation of methane hydrate in porous media [J]. Editorial office of ACTA PETROLEI SINICA, 2009, 30(4): 583-587.