鄂尔多斯盆地页岩油开发井网优化技术及实践——以庆城油田为例

doi:10.7623/syxb202404006

石油学报 ›› 2024, Vol. 45 ›› Issue (4): 683-697.DOI: 10.7623/syxb202404006

鄂尔多斯盆地页岩油开发井网优化技术及实践——以庆城油田为例

何永宏¹, 李桢^2,3, 樊建明^2,3, 张超^2,3, 张旭泽^2,3, 马兵^3,4

1. 中国石油长庆油田公司陕西西安 710018;
2. 中国石油长庆油田公司勘探开发研究院陕西西安 710018;
3. 低渗透油气田勘探开发国家工程实验室陕西西安 710018;
4. 中国石油长庆油田公司油气工艺研究院陕西西安 710018

收稿日期:2023-02-13 修回日期:2024-02-02 出版日期:2024-04-25 发布日期:2024-05-08
通讯作者: 李桢,女,1988年12月生,2018年获中国石油大学(北京)博士学位,现为中国石油长庆油田公司勘探开发研究院高级工程师,主要从事页岩油勘探开发研究工作。Email:lizhenlz_cq@petrochina.com.cn
作者简介:何永宏,男,1974年11月生,1997年获西南石油学院学士学位,现为中国石油长庆油田公司副总经理、教授级高级工程师,主要从事非常规油藏开发研究和技术管理工作。Email:hyh2_cq@petrochina.com.cn
基金资助:
中国石油天然气股份有限公司攻关性应用性科技专项"陆相页岩油开发优化技术研究与试验"(2023ZZ15YJ03)和中国石油长庆油田公司重大专项"鄂尔多斯盆地页岩油渗流机理及有效开发关键技术研究"(2023DZZ04)资助。

Optimization technique of development well pattern of shale oil in Ordos Basin and its application: a case study of Qingcheng oilfield

He Yonghong¹, Li Zhen^2,3, Fan Jianming^2,3, Zhang Chao^2,3, Zhang Xuze^2,3, Ma Bing^3,4

1. PetroChina Changqing Oilfield Company, Shaanxi Xi'an 710018, China;
2. Research Institute of Exploration and Development, PetroChina Changqing Oilfield Company, Shaanxi Xi'an 710018, China;
3. National Engineering Laboratory for Exploration and Development of Low-Permeability Oil & Gas Fields, Shaanxi Xi'an 710018, China;
4. Oil & Gas Technology Research Institute, PetroChina Changqing Oilfield Company, Shaanxi Xi'an 710018, China

Received:2023-02-13 Revised:2024-02-02 Online:2024-04-25 Published:2024-05-08

摘要/Abstract

摘要： 鄂尔多斯盆地庆城页岩油纵向油层多期叠置,横向非均质性强、变化快,开发井网优化难度大。针对庆城页岩油地质特征,为实现储量动用程度最大化,综合利用矿场实践、油藏工程和数值模拟等方法对水平段方位、长度、井距和立体开发井网合理隔层开展了系统研究。研究结果表明:水平井的方位主体采用与最大主应力方向垂直的方案,但在靶前区、地面受限区要综合考虑砂体展布方向、地下储量动用程度和地面井场位置,水平段布井方位可以适当偏转;优化水平段长度主体为1 500 m,受砂体延伸长度短影响的水平段长度为600~800 m;优化单井控制储量为(25~30)×10⁴t,主体井距为500 m,不同油层厚度部署区有所差异;纵向上隔层厚度大于10 m的油层段开展立体开发。基于以上研究,形成了页岩油多层系立体式布井模式。研究成果支撑庆城油田页岩油单井EUR达到(2.6~2.8)×10⁴t,产油量达到165×10⁴t/a,实现了规模效益开发。

关键词: 鄂尔多斯盆地, 庆城油田, 页岩油, 开发井网, 优化技术, 实践

Abstract: The shale oil reservoirs in Qingcheng oilfield, located in Ordos Basin, are characterized by multiple periods of vertically stacked oil layers and strong lateral heterogeneity, making it challenging to optimize the development well pattern. Based on considering the geological characteristics of shale oil reservoirs in Qingcheng oilfield, and comprehensively using the methods of oilfield application, reservoir engineering and numerical simulation, a systematic study was conducted on the orientation, length, well spacing, three-dimensional well pattern development, and reasonable stratification of the horizontal section, so as to maximize the utilization of reserves. The results show that the main orientation of horizontal wells should be perpendicular to the maximum principal stress direction; however, taking into account the distribution direction of sand bodies, the utilization of underground reserves, and the location of surface well site, the orientation of wells in horizontal section can be appropriately deviated in the target front area and restricted surface area. The optimal length of horizontal section is mainly 1 500 m, and the length of the horizontal section affected by the extension of sand body is within the range of 600 m to 800 m. The optimized controllable reserves per well is (25-30)×10⁴ t, and generally the well spacing is 500 m; there are various deployment areas in the oil layers of different thickness. The three-dimensional development technique is applied for the oil layers with a vertically stratified thickness greater than 10 m. Based on the above study, a three-dimensional well pattern has been established for the multi-layered shale oil reservoirs. The research results present a single well estimated ultimate recovery (EUR) of (2.6-2.8)×10⁴ t and an annual oil production of 165×10⁴ t in Qingcheng oilfield, achieving large-scale efficient development.

Key words: Ordos Basin, Qingcheng oilfield, shale oil, development well pattern, optimization technique, application

中图分类号:

TE349

何永宏, 李桢, 樊建明, 张超, 张旭泽, 马兵. 鄂尔多斯盆地页岩油开发井网优化技术及实践——以庆城油田为例[J]. 石油学报, 2024, 45(4): 683-697.

He Yonghong, Li Zhen, Fan Jianming, Zhang Chao, Zhang Xuze, Ma Bing. Optimization technique of development well pattern of shale oil in Ordos Basin and its application: a case study of Qingcheng oilfield[J]. Acta Petrolei Sinica, 2024, 45(4): 683-697.

参考文献

[1] 焦方正,邹才能,杨智.陆相源内石油聚集地质理论认识及勘探开发实践[J].石油勘探与开发,2020,47(6):1067-1078.
JIAO Fangzheng,ZOU Caineng,YANG Zhi.Geological theory and exploration&development practice of hydrocarbon accumulation inside continental source kitchens[J].Petroleum Exploration and Development,2020,47(6):1067-1078.
[2] 金之钧,王冠平,刘光祥,等.中国陆相页岩油研究进展与关键科学问题[J].石油学报,2021,42(7):821-835.
JIN Zhijun,WANG Guanping,LIU Guangxiang,et al.Research progress and key scientific issues of continental shale oil in China[J].Acta Petrolei Sinica,2021,42(7):821-835.
[3] 赵文智,胡素云,侯连华,等.中国陆相页岩油类型、资源潜力及与致密油的边界[J].石油勘探与开发,2020,47(1):1-10.
ZHAO Wenzhi,HU Suyun,HOU Lianhua,et al.Types and resource potential of continental shale oil in China and its boundary with tight oil[J].Petroleum Exploration and Development,2020,47(1):1-10.
[4] 杨华,李士祥,刘显阳.鄂尔多斯盆地致密油、页岩油特征及资源潜力[J].石油学报,2013,34(1):1-11.
YANG Hua,LI Shixiang,LIU Xianyang.Characteristics and resource prospects of tight oil and shale oil in Ordos Basin[J].Acta Petrolei Sinica,2013,34(1):1-11.
[5] 邹才能,张国生,杨智,等.非常规油气概念、特征、潜力及技术--兼论非常规油气地质学[J].石油勘探与开发,2013,40(4):385-399.
ZOU Caineng,ZHANG Guosheng,YANG Zhi,et al.Geological concepts,characteristics,resource potential and key techniques of unconventional hydrocarbon:on unconventional petroleum geology[J].Petroleum Exploration and Development,2013,40(4):385-399.
[6] 付金华,李士祥,牛小兵,等.鄂尔多斯盆地三叠系长7段页岩油地质特征与勘探实践[J].石油勘探与开发,2020,47(5):870-883.
FU Jinhua,LI Shixiang,NIU Xiaobing,et al.Geological characteristics and exploration of shale oil in Chang 7 Member of Triassic Yanchang Formation,Ordos Basin,NW China[J].Petroleum Exploration and Development,2020,47(5):870-883.
[7] 金之钧,朱如凯,梁新平,等.当前陆相页岩油勘探开发值得关注的几个问题[J].石油勘探与开发,2021,48(6):1276-1287.
JIN Zhijun,ZHU Rukai,LIANG Xinping,et al.Several issues worthy of attention in current lacustrine shale oil exploration and development[J].Petroleum Exploration and Development,2021,48(6):1276-1287.
[8] 付锁堂,姚泾利,李士祥,等.鄂尔多斯盆地中生界延长组陆相页岩油富集特征与资源潜力[J].石油实验地质,2020,42(5):698-710.
FU Suotang,YAO Jingli,LI Shixiang,et al.Enrichment characteristics and resource potential of continental shale oil in Mesozoic Yanchang Formation,Ordos Basin[J].Petroleum Geology&Experiment,2020,42(5):698-710.
[9] 付金华,李士祥,郭芪恒,等.鄂尔多斯盆地陆相页岩油富集条件及有利区优选[J].石油学报,2022,43(12):1702-1716.
FU Jinhua,LI Shixiang,GUO Qiheng,et al.Enrichment conditions and favorable area optimization of continental shale oil in Ordos Basin[J].Acta Petrolei Sinica,2022,43(12):1702-1716.
[10] 侯连华,吴松涛,姜晓华,等.页岩油地质评价实验方法现状、挑战与发展方向[J].石油学报,2023,44(01):72-90.
HOU Lianhua,WU Songtao,JIANG Xiaohua,et al.Situation,challenge and future direction of experimental methods for geological evaluation of shale oil[J].Acta Petrolei Sinica,2023,44(1):72-90.
[11] 李阳,赵清民,吕琦,等.中国陆相页岩油开发评价技术与实践[J].石油勘探与开发,2022,49(5):955-964.
LI Yang,ZHAO Qingmin,LV Qi,et al.Evaluation technology and practice of continental shale oil development in China[J].Petroleum Exploration and Development,2022,49(5):955-964.
[12] 雷群,翁定为,熊生春,等.中国石油页岩油储集层改造技术进展及发展方向[J].石油勘探与开发,2021,48(5):1035-1042.
LEI Qun,WENG Dingwei,XIONG Shengchun,et al.Progress and development directions of shale oil reservoir stimulation technology of China National Petroleum Corporation[J].Petroleum Exploration and Development,2021,48(5):1035-1042.
[13] BALASUBRAMANIAN S,CHEN Peila,BOSE S,et al.Recent advances in enhanced oil recovery technologies for unconventional oil reservoirs[C]//Offshore Technology Conference.Houston:Society of Petroleum Engineers,2018.
[14] WANG Lei,TIAN Ye,YU Xiangyu,et al.Advances in improved/enhanced oil recovery technologies for tight and shale reservoirs[J].Fuel,2017,210:425-445.
[15] 翁定为,雷群,管保山,等.中美页岩油气储层改造技术进展及发展方向[J].石油学报,2023,44(12):2297-2307.
WENG Dingwei,LEI Qun,GUAN Baoshan,et al.Progress and development directions of reservoir stimulation techniques for shale oil and gas in China and the United States[J].Acta Petrolei Sinica,2023,44(12):2297-2307.
[16] 李国欣,刘国强,侯雨庭,等.陆相页岩油有利岩相优选与压裂参数优化方法[J].石油学报,2021,42(11):1405-1416.
LI Guoxin,LIU Guoqiang,HOU Yuting,et al.Optimization method of favorable lithofacies and fracturing parameter for continental shale oil[J].Acta Petrolei Sinica,2021,42(11):1405-1416.
[17] 樊建明,屈雪峰,王冲,等.超低渗透油藏水平井注采井网设计优化研究[J].西南石油大学学报:自然科学版,2018,40(2):115-128.
FAN Jianming,QU Xuefeng,WANG Chong,et al.Optimization study of the horizontal well and injection-production pattern in an ultra-low-permeability reservoir[J].Journal of Southwest Petroleum University:Science&Technology Edition,2018,40(2):115-128.
[18] 赵继勇,何永宏,樊建明,等.超低渗透致密油藏水平井井网优化技术研究[J].西南石油大学学报:自然科学版,2014,36(2):91-98.
ZHAO Jiyong,HE Yonghong,FAN Jianming,et al.Optimization technology for horizontal well pattern in ultra-low permeable tight reservoirs[J].Journal of Southwest Petroleum University:Science&Technology Edition,2014,36(2):91-98.
[19] 吴胜和,纪友亮,岳大力,等.碎屑沉积地质体构型分级方案探讨[J].高校地质学报,2013,19(1):12-22.
WU Shenghe,JI Youliang,YUE Dali,et al.Discussion on hierarchical scheme of architectural units in clastic deposits[J].Geological Journal of China Universities,2013,19(1):12-22.
[20] 屈雪峰,王武荣,谢启超,等.坳陷湖盆湖底扇储层单砂体构型--以鄂尔多斯盆地合水地区三叠系长6油层组为例[J].地球科学与环境学报,2021,43(5):850-867.
QU Xuefeng,WANG Wurong,XIE Qichao,et al.Single sandbody architecture of sublacustrine fan in a depression lacustrine basin:insights from Triassic Chang-6 oil-bearing interval in Heshui area of Ordos Basin,China[J].Journal of Earth Sciences and Environment,2021,43(5):850-867.
[21] 中国石油天然气股份有限公司规划总院,中国石油天然气集团公司油气勘探开发投资项目经济评价方法(2017)[R].北京:中国石油规划总院,2017
PetroChina Planning&Engineering Institute.Economic Evaluation method for oil and gas exploration and development investment projects of CNPC (2017)[R].Beijing:PetroChina Planning&Engineering Institute,2017.
[22] 中国石油天然气股份有限公司规划总院,中国石油天然气集团有限公司投资项目经济评价参数(2020)[R].北京:中国石油规划总院,2020.
PetroChina Planning&Engineering Institute.Economic evaluation parameters for investment projects of CNPC (2020)[R].Beijing:PetroChina Planning&Engineering Institute,2020.
[23] 吴胜和,岳大力,蒋裕强.油矿地质学[M].5版.北京:石油工业出版社,2021:332-360.
WU Shenghe,YUE Dali,JIANG Yuqiang.Oilfield subsurface geology[M].5th ed.Beijing:Petroleum Industry Press,2021:332-360.
[24] 赵继勇,樊建明,薛婷,等.鄂尔多斯盆地长7致密油储渗特征及分类评价研究[J].西北大学学报(自然科学版),2018,48(6):857-866.
ZHAO Jiyong,FAN Jianming,XUE Ting,et al.Classification and evaluation of Chang 7 tight oil reservoir seepage features in Ordos Basin[J].Journal of Northwest University (Natural Science Edition),2018,48(6):857-866.
[25] 樊建明,杨子清,李卫兵,等.鄂尔多斯盆地长7致密油水平井体积压裂开发效果评价及认识[J].中国石油大学学报(自然科学版),2015,39(4):103-110.
FAN Jianming,YANG Ziqing,LI Weibing,et al.Assessment of fracturing treatment of horizontal wells using SRV technique for Chang-7 tight oil reservoir in Ordos Basin[J].Journal of China University of Petroleum (Edition of Natural Science),2015,39(4):103-110.
[26] 樊建明,陈小东,雷征东,等.鄂尔多斯盆地致密油藏天然裂缝与人工裂缝特征及开发意义[J].中国石油大学学报(自然科学版),2019,43(3):98-106.
FAN Jianming,CHEN Xiaodong,LEI Zhengdong,et al.Characteristics of natural and hydraulic fractures in tight oil reservoir in Ordos Basin and its implication to field development[J].Journal of China University of Petroleum (Edition of Natural Science),2019,43(3):98-106.
[27] 李宁,冯周,武宏亮,等.中国陆相页岩油测井评价技术方法新进展[J].石油学报,2023,44(1):28-44
LI Ning,FENG Zhou,WU Hongliang,et al.New advances in methods and technologies for well logging evaluation of continental shale oil in China[J].Acta Petrolei Sinica,2023,44(1):28-44.

鄂尔多斯盆地页岩油开发井网优化技术及实践——以庆城油田为例

Optimization technique of development well pattern of shale oil in Ordos Basin and its application: a case study of Qingcheng oilfield

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	何文渊, 崔宝文, 张金友, 赵莹, 程心阳, 刘召, 刘鑫, 曾花森. 松辽盆地北部嫩江组中—低成熟页岩油地质特征及勘探突破[J]. 石油学报, 2024, 45(6): 900-913.
[2]	刘胜男, 朱如凯, 靳军, 张婧雅. 油气运移约束陆相页岩油富集——以准噶尔盆地吉木萨尔凹陷芦草沟组为例[J]. 石油学报, 2024, 45(6): 932-946.
[3]	周立宏, 陈长伟, 杨飞, 李宏军, 刘国全, 崔宇, 吴雪松, 石倩茹, 徐雯婧, 董文韬. 陆相断陷盆地深凹区致密油气成藏模式与勘探实践——以渤海湾盆地黄骅坳陷为例[J]. 石油学报, 2024, 45(5): 755-770.
[4]	解德录, 赵贤正, 金凤鸣, 蒲秀刚, 韩文中, 时战楠, 张伟, 董雄英. 沧东凹陷深湖亚相纹层状页岩成因及页岩油可动性影响因素[J]. 石油学报, 2024, 45(5): 804-816.
[5]	熊钰, 郭美娟, 王羚鸿, 吴道铭, 陈美华, 李明秋, 邓波, 张芮, 路俊刚, 曾德铭. 四川盆地侏罗系大安寨段页岩油特征及可动性评价[J]. 石油学报, 2024, 45(5): 817-843.
[6]	侯连华, 米敬奎, 罗霞, 于志超, 林森虎, 廖凤荣, 庞正炼, 赵忠英. 压力对页岩原位加热产出油气特征的影响——以鄂尔多斯盆地三叠系延长组7段3亚段页岩为例[J]. 石油学报, 2024, 45(4): 629-641.
[7]	杨勇, 张世明, 吕琦, 杜玉山, 李伟忠, 程紫燕, 吕晶, 刘祖鹏. 中国东部陆相断陷盆地中—低成熟度页岩油立体开发技术——以济阳坳陷古近系沙河街组为例[J]. 石油学报, 2024, 45(4): 672-682,697.
[8]	武晓光, 龙腾达, 黄中伟, 高文龙, 李根生, 谢紫霄, 杨芮, 鲁京松, 马金亮. 页岩油多岩性交互储层径向井穿层压裂裂缝扩展特征[J]. 石油学报, 2024, 45(3): 559-573,585.
[9]	宋兆杰, 邓森, 宋宜磊, 刘勇, 鲜成钢, 张江, 韩啸, 曹胜, 付兰清, 崔焕琦. 大庆油田古龙页岩油-CO₂高压相态及传质规律[J]. 石油学报, 2024, 45(2): 390-402.
[10]	吴宝成, 吴承美, 谭强, 褚艳杰, 梁成钢, 李文波, 张金风, 陈依伟, 徐田录, 王良哲. 准噶尔盆地吉木萨尔凹陷昌吉页岩油成藏条件及勘探开发关键技术[J]. 石油学报, 2024, 45(2): 437-460.
[11]	席胜利, 闫伟, 刘新社, 张才利, 殷亮亮, 董国栋, 井向辉, 魏柳斌. 鄂尔多斯盆地天然气勘探新领域、新类型及资源潜力[J]. 石油学报, 2024, 45(1): 33-51,132.
[12]	李志军, 肖阳, 田建章, 李晓燕, 王元杰, 王海燕, 焦亚先, 汤小琪, 贾颖超, 任春玲, 严梦颖, 王成云, 任艺. 渤海湾盆地冀中坳陷新领域、新类型油气勘探潜力及有利方向[J]. 石油学报, 2024, 45(1): 69-98.
[13]	支东明, 李建忠, 周志超, 焦立新, 范谭广, 李斌, 梁辉, 王兴刚. 三塘湖盆地油气勘探开发新领域、新类型及资源潜力[J]. 石油学报, 2024, 45(1): 115-132.
[14]	朱相羽, 段宏亮, 孙雅雄. 苏北盆地高邮凹陷古近系陆相页岩油勘探突破及意义[J]. 石油学报, 2023, 44(8): 1206-1221,1257.
[15]	陶士振, 胡素云, 王建, 白斌, 庞正炼, 王民, 陈燕燕, 陈悦, 杨怡青, 金旭, 贾进华, 张天舒, 林森虎, 孟元林, 刘鸿儒, 王岚, 吴因业. 中国陆相致密油形成条件、富集规律与资源潜力[J]. 石油学报, 2023, 44(8): 1222-1239.