Study on laying technology of products pipeline along with hot crude pipeline in one ditch

doi:10.7623/syxb200705029

Editorial office of ACTA PETROLEI SINICA ›› 2007, Vol. 28 ›› Issue (5): 149-152.DOI: 10.7623/syxb200705029

• Petroleum Engineering • Previous Articles

Study on laying technology of products pipeline along with hot crude pipeline in one ditch

Yu Bo, Ling Xiao, Zhang Jinjun, Wang Yi

Key Laboratory for Urban Oil and Gas Distribution Technology, College of Petroleum Engineering, China University of Petroleum, Beijing 102249, China

Received:2006-11-12 Revised:2007-03-02 Online:2007-09-25 Published:2010-08-06

成品油管道与热原油管道同沟敷设技术研究

宇波, 凌霄, 张劲军, 王艺

中国石油大学石油天然气工程学院城市油气输配技术重点实验室北京102249

作者简介:宇波,男,1972年8月生,1999年获西安交通大学博士学位,现为中国石油大学(北京)油气储运工程系教授,主要从事长距离原油输送工艺、添加剂湍流减阻、强化传热、CFD/NHT数值计算方法等方面的研究.E-mail:yubobox@cup.edu.cn
基金资助:
国家自然科学基金项目(No.50506017);国家高技术研究发展计划项目(2006AA09Z357);中国石油天然气股份有限公司科技风险创新研究项目联合资助

Abstract

Abstract: The heat transmission of products pipeline along with hot crude pipeline in one ditch has some effects on the operation of crude oil pipeline.The unstructured-finite-volume method was used to investigate the complex flow and heat transfer state in the products pipeline and hot crude pipeline laying in one ditch by numerical simulation.The hydraulic and thermal calculations of single crude pipeline and two pipelines for products and crude oil under the same condition were carried out.The result shows that the temperature of crude oil in the pipeline is almost unaffected by the products pipeline,when the interval between two pipelines was 1.2 meters.

Key words: oil pipeline, products pipeline, Laying technology of two pipelines in one ditch, flow and heat transfer interaction, unstructured-finite-volume method, numerical simulation

摘要： 同沟敷设管道中成品油管道和原油管道间的传热对原油管道的运行有一定的影响。采用非结构化有限容积法,对成品油和原油管道内复杂的流动和传热问题进行了数值模拟。为了确定同沟敷设成品油管道对原油管道的影响,对相同条件下单独敷设的原油管道进行了水力和热力计算,并与同沟敷设管道的计算结果进行了对比。结果表明,两条管道的间距取1.2m时,原油管道沿线温度受成品油管道的影响较小。

关键词: 原油管道, 成品油管道, 同沟敷设技术, 流动-传热耦合, 非结构化有限容积法, 数值模拟

CLC Number:

TE732

Yu Bo, Ling Xiao, Zhang Jinjun, Wang Yi. Study on laying technology of products pipeline along with hot crude pipeline in one ditch[J]. Editorial office of ACTA PETROLEI SINICA, 2007, 28(5): 149-152.

宇波, 凌霄, 张劲军, 王艺. 成品油管道与热原油管道同沟敷设技术研究[J]. 石油学报, 2007, 28(5): 149-152.

[1]	Liu Shiqi, Tian Yuchen, Zhang Helong, Sang Shuxun, Wang Wenkai, Bai Yansong, Zhang Guoxin, Zheng Sijian, Han Sijie. Research progress on multiphase and multicomponent fluid flow mechanisms during CO₂-enhanced coalbed methane recovery and sequestration [J]. Acta Petrolei Sinica, 2026, 47(1): 217-240.
[2]	Cao Bao, Mi Lidong, Xie Kun, Lu Xiangguo, Wen Guofeng, Tian Fuchun. Numerical simulation method for multiphase and multicomponent flow in ultra-low permeability and tight oil reservoirs based on discrete fracture model [J]. Acta Petrolei Sinica, 2025, 46(4): 763-778.
[3]	Yao Jun, Wang Tong, Sun Zhixue, Sun Hai, Huang ZhaoQin. Massively parallel numerical simulation technology for thermo-hydro-mechanical coupling using general embedded discrete fracture model [J]. Acta Petrolei Sinica, 2025, 46(3): 574-587.
[4]	Zhang Hewei, Shen Jian, Wu Caifang, Cai Ying, Zhang Zheng, Wang Qian. Response of enhancing coalbed methane recovery by N₂-CO₂ mixed gas injection and optimization of injection ratio under the regulation of adsorption-diffusion heterogeneity for different coal lithotypes [J]. Acta Petrolei Sinica, 2025, 46(12): 2343-2357.
[5]	Yan Xia, Xiong Xianyue, Wang Feng, Ma Ruishuai, Yuan Pu, Ji Liang, Sun Junyi, Zhang Jiyuan, Yang Hongtao, Li Chunhu, Zhang Tong, Yin Zesong. Mechanism and practical significance of velocity sensitivity effects in propped fractures of deep coal seams [J]. Acta Petrolei Sinica, 2025, 46(12): 2374-2388.
[6]	Wei Bing, Yang Mengke, Zhao Jinzhou, Kadet Valeriy, Pu Wanfen. Steady-state flow regimes and numerical simulation method of supercritical CO₂ foam in porous media [J]. Acta Petrolei Sinica, 2024, 45(7): 1122-1129.
[7]	Ji Bingyu, Zhang Wenbiao, He Yingfu, Duan Taizhong, Liu He. Connotation and development trends of integration between geological reservoir modeling and numerical reservoir simulation [J]. Acta Petrolei Sinica, 2024, 45(7): 1152-1162.
[8]	Li Zhen, Guo Qi, Bu Yahui, Hu Huifang. Establishment and prediction of sample pool of saturation field based on deep learning [J]. Acta Petrolei Sinica, 2024, 45(4): 698-707.
[9]	Zhang Hong, Wu Kai, Feng Qingshan, Sui Yongli, Liu Xiaoben, Yang Yue, Yang Die, Dai Lianshuang, Wang Dongying, Wang Chong. Relationship between fracture toughness and crack tip constraint of high-strength pipe girth welds [J]. Acta Petrolei Sinica, 2023, 44(2): 385-393.
[10]	Wang Qiang, Zhao Jinzhou, Hu Yongquan, Zhao Chaoneng, Zhang Zhenxiang. Numerical simulation of static spontaneous imbibition at the core scale [J]. Acta Petrolei Sinica, 2022, 43(6): 860-870.
[11]	Wu Lin, Zhu Ming, Feng Xingqiang, Ji Dongsheng, Zhou Lei, Liu Shengxin, Zhang Linyan, Tan Yuanlong, Qian Zhuliang, Yang Zhen. Interpretation on tectonic stress and deformation of Sikeshu sag in Junggar Basin [J]. Acta Petrolei Sinica, 2022, 43(4): 494-506.
[12]	Xu Lin, Liu Shujie, Xu Mingbiao, Feng Huanzhi, Xing Xijin, Deng Jiajia. Self-adaptive repair behavior and mechanism of micro-defects of differential pressure activated sealant [J]. Acta Petrolei Sinica, 2021, 42(5): 686-694.
[13]	Zou Wei, Yu Yixin, Liu Jinshui, Jiang Yiming, Tang Xianjun, Chen Shi, Yu Lang. Main controlling factors of the central inversional structure belt and the development of Ningbo anticline in Xihu sag,East China Sea Basin [J]. Acta Petrolei Sinica, 2021, 42(2): 176-185.
[14]	Lu Hailong, Shang Shilong, Chen Xuejun, Qin Xuwen, Gu Lijuan, Qiu Haijun. Research progress and development direction of numerical simulator for natural gas hydrate development [J]. Acta Petrolei Sinica, 2021, 42(11): 1516-1530.
[15]	Zhu Xiaohua, Luo Yunxu, Liu Weiji, Gao Rui, Jia Yudan, Liu Chengjun. Electrical breakdown experiment and numerical simulation method of rock-breaking mechanism of plasma electric pulse drilling [J]. Acta Petrolei Sinica, 2020, 41(9): 1146-1162.

Study on laying technology of products pipeline along with hot crude pipeline in one ditch

成品油管道与热原油管道同沟敷设技术研究

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments