耦合双重分形蚓孔的表皮因子计算模型

doi:10.7623/syxb201706012

石油学报 ›› 2017, Vol. 38 ›› Issue (6): 721-728.DOI: 10.7623/syxb201706012

耦合双重分形蚓孔的表皮因子计算模型

张合文^1,2, 丁云宏¹, 邹洪岚¹, 鄢雪梅¹, 崔明月¹, 梁冲¹, 张曙振³

1. 中国石油勘探开发研究院北京 100083;
2. 中国矿业大学地球科学与测绘工程学院北京 100083;
3. 中国石油塔里木油田公司新疆库尔勒 841000

收稿日期:2016-10-13 修回日期:2017-04-26 出版日期:2017-06-25 发布日期:2017-07-08
通讯作者: 张合文,男,1982年11月生,2005年获中国石油大学(华东)学士学位,2015年获中国科学院大学博士学位,现为中国石油勘探开发研究院工程师,主要从事油气藏增产改造理论与技术研究工作。Email:etczhanghw@163.com
作者简介:张合文,男,1982年11月生,2005年获中国石油大学(华东)学士学位,2015年获中国科学院大学博士学位,现为中国石油勘探开发研究院工程师,主要从事油气藏增产改造理论与技术研究工作。Email:etczhanghw@163.com
基金资助:
国家重大科技专项（2011ZX05059，2017ZX05030-005）资助。

Skin factor calculation model coupled with dual fractal wormhole

Zhang Hewen^1,2, Ding Yunhong¹, Zou Honglan¹, Yan Xuemei¹, Cui Mingyue¹, Liang Chong¹, Zhang Shuzhen³

1. PetroChina Research Institute of Petroleum Exploration and Development, Beijing 100083, China;
2. College of Geoscience and Surveying Engineering, China University of Mining & Technology, Beijing 100083, China;
3. PetroChina Tarim Oilfield Company, Xinjiang Korla 841000, China

Received:2016-10-13 Revised:2017-04-26 Online:2017-06-25 Published:2017-07-08

摘要/Abstract

摘要：

基质酸化是碳酸盐岩油气藏最经济有效的增产方式之一，表皮因子是此类油藏酸化设计中的关键因素。鉴于酸岩反应影响因素多，酸蚀蚓孔生长随机性强，且呈分支型体积展布，以往的表皮因子计算模型通常只将其简化为一等效半径，计算结果可靠性较低。为此，引入了以不规则几何形态为研究对象的分形几何学方法，验证了室内实验得到的单蚓孔平面分布的分形性，得到了其分形维数及单蚓孔长度扩展模型。结合Golfier模型，对多蚓孔同时扩展模拟结果进行了分析，建立了描述多蚓孔间竞争分布的双重分形数学模型。在此基础上，按照酸蚀蚓孔长度与污染半径间对比关系，将表皮因子计算模型改进为两区模型、三区模型和交叉分布模型3种模式。结合现场实际数据，对计算结果进行了参数敏感性分析。根据表皮因子随用酸量、施工排量的变化趋势可以优选施工参数，渗透率差异系数代表储层污染程度，也是影响表皮因子和增产效果的重要因素和选井选层的重要依据。对比表明，通过常规等效半径模型得到的表皮因子小于双重分形模型下的计算值，这也解释了碳酸盐岩储层在负表皮因子下，经过酸化后仍能增产的原因。

关键词: 碳酸盐岩, 酸化, 蚓孔, 双重分形, 表皮因子, 耦合

Abstract:

Matrix acidizing is one of the most cost-effective methods to increase the oil yield from carbonate reservoirs, and the calculation of skin factor is the most critical parameter in designing acidification process for such reservoirs. Because of multiple factors affecting acid-rock reaction, the high randomness and branching-type distribution of acid wormhole growth, wormholes were usually simplified as an equivalent radius in conventional skin factor models, thus resulting in the low reliability of calculation results. Therefore, the fractal geometry method focus on studying irregular geometry was introduced to validate the fractal property of single-wormhole planar distribution obtained by laboratory experiments, so as to obtain the fractal dimensions and single-wormhole length extension model. In combination with Golfier model, the simulation results of multi-wormhole simultaneous expansion were analyzed to establish the dual fractal model describing multi-wormhole competitive distribution. On this basis, the skin factor calculation model was improved according to the relativities between acid wormhole length and pollution radius, and evolved into two-region model, three-region model and cross-distribution model. Based on actual field data, parameter sensitivity analysis was conducted on calculation results. Operation parameters can be optimized in consideration of the changing skin factor trend with acid volume and pumping rate. Permeability difference coefficient represents formation pollution degree, taken as not only the important factor affecting skin factor and stimulation effect, but also a key foundation for well and layer selection. The comparative results show that the skin factor obtained by conventional equal-radius model is less than the calculation value of dual fractal model. This also well explains why oil yield can be increased even by acidizing the carbonate reservoirs with negative skin factor.

Key words: carbonate, acidizing, wormhole, dual fractal, skin factor, coupling

中图分类号:

TE344

张合文, 丁云宏, 邹洪岚, 鄢雪梅, 崔明月, 梁冲, 张曙振. 耦合双重分形蚓孔的表皮因子计算模型[J]. 石油学报, 2017, 38(6): 721-728.

Zhang Hewen, Ding Yunhong, Zou Honglan, Yan Xuemei, Cui Mingyue, Liang Chong, Zhang Shuzhen. Skin factor calculation model coupled with dual fractal wormhole[J]. Acta Petrolei Sinica, 2017, 38(6): 721-728.

参考文献

[1] 张光亚,马锋,梁英波,等.全球深层油气勘探领域及理论技术进展[J].石油学报,2015,36(9):1156-1166.
ZHANG Guangya,MA Feng,LIANG Yingbo,et al.Domain and theory-technology progress of global deep oil & gas exploration[J].Acta Petrolei Sinica,2015,36(9):1156-1166.
[2] 贾小乐,何登发,童晓光,等.全球大油气田分布特征[J].中国石油勘探,2011,16(3):1-7.
JIA Xiaole,HE Dengfa,TONG Xiaoguang,et al.Distribution of global giant oil and gas fields[J].China Petroleum Exploration,2011,16(3):1-7.
[3] 贾承造,庞雄奇.深层油气地质理论研究进展与主要发展方向[J].石油学报,2015,36(12):1457-1469.
JIA Chengzao,PANG Xiongqi.Research processes and main development directions of deep hydrocarbon geological theories[J].Acta Petrolei Sinica,2015,36(12):1457-1469.
[4] 任龙,苏玉亮,郝永卯,等.基于改造模式的致密油藏体积压裂水平井动态分析[J].石油学报,2015,36(10):1272-1279.
REN Long,SU Yuliang,HAO Yongmao,et al.Dynamic analysis of SRV-fractured horizontal wells in tight oil reservoirs based on stimulated patterns[J].Acta Petrolei Sinica,2015,36(10):1272-1279.
[5] 曾青冬,姚军.水平井多裂缝同步扩展数值模拟[J].石油学报,2015,36(12):1571-1579.
ZENG Qingdong,YAO Jun.Numerical simulation of multiple fractures simultaneous propagation in horizontal wells[J].Acta Petrolei Sinica,2015,36(12):1571-1579.
[6] GLASBERGEN G,VAN BATENBURG D W,VAN DOMELEN M S,et al.Field validation of acidizing wormhole models[R].SPE 94695,2005.
[7] KALIA N,GLASBERGEN G.Wormhole formation in carbonates under varying temperature conditions[R].SPE 121803,2009.
[8] FREDD C N.Dynamic model of wormhole formation demonstrates conditions for effective skin reduction during carbonate matrix acidizing[R].SPE 59537,2000.
[9] MORGENTHALER L.Technology focus:matrix stimulation[J].Journal of Petroleum Technology,2014,66(6):90.
[10] 张汝生,卢拥军,丁云宏.碳酸盐岩基质酸化/酸压裂中形成虫孔研究新进展[J].油田化学,2005,22(3):276-278.
ZHANG Rusheng,LU Yongjun,DING Yunhong.New developments in understanding wormholing in carbonate formations during matrix acidizing/acid fracturing[J].Oilfield Chemistry,2005,22(3):276-278.
[11] 柳明,张士诚,牟建业.酸蚀蚓孔的分形性和酸液类型对蚓孔的影响[J].石油勘探与开发,2012,39(5):591-596.
LIU Ming,ZHANG Shicheng,MOU Jianye.Fractal nature if acid-etched wormholes and the influence if acid type on wormholes[J].Petroleum Exploration and Development,2012,39(5):591-596.
[12] GLASBERGEN G,KALIA N,TALBOT M S.The optimum injection rate for wormhole propagation:myth or reality?[R].SPE 121464,2009.
[13] PANGA M K R,ZIAUDDIN M,GANDIKOTA R,et al.A new model for predicting wormhole structure and formation in acid stimulation of carbonates[R].SPE 86517,2004.
[14] Dong Kai,Zhu Ding,HILL A D.Theoretical and experimental study on optimal injection rates in carbonate acidizing[R].SPE 178961,2016.
[15] 牟建业,李双明,赵鑫,等.基于真实孔隙空间分布的酸蚀蚓孔扩展规律数值模拟研究[J].科学技术与工程,2014,14(35):40-46.
MOU Jianye,LI Shuangming,ZHAO Xin,et al.Modeling wormhole propataition behavior based on real pore spatial distributions[J].Science Technology and Engineering,2014,14(35):40-46.
[16] AL-DUAILEJ Y K,KWAK H T,CALISKAN S,et al.Wormhole characterisation using NMR:International Petroleum Technology Conference,Beijing,China,26-28 March 2013[C].Beijing:International Petroleum Technology Conference,2013.
[17] 王新海,张福祥,姜永,等.岩心污染表皮系数的计算[J].天然气工业,2012,32(12):52-54.
WANG Xinhai,ZHANG Fuxiang,JIANG Yong,et al.Calculation of skin factor of contaminated cores[J].Natural Gas Industry,2012,32(12):52-54.
[18] GHAHRI P,JAMIOLAHMADY M,SOHRABI M.New skin factor formulations for flow around horizontal wells including anisotropy and inertia[R]. SPE 121109,2009.
[19] FURUI K,ZHU D,HILL A D.A new skin-factor model for perforated horizontal wells[J]. SPE Drilling & Completion,2008,23(3):205-215.
[20] LIU Ming,ZHANG Shicheng,MOU Jianye.Effect of normally distributed porosities on dissolution pattern in carbonate acidizing[J].Journal of Petroleum Science and Engineering,2012,94-95:28-39.
[21] 张济忠.分形[M].2版.北京:清华大学出版社,2011.
ZHANG Jizhong.Fractal[M].2nd ed.Beijing:Tsinghua University Press,2011.
[22] MCDUFF D R,SHUCHART C E,JACKSON S,et al.Understanding wormholes in carbonates:unprecedented experimental scale and 3-D visualization[R].SPE 134379,2010.
[23] BUIJSE M A,GLASBERGEN G.A semi-empirical model to calculate wormhole growth in carbonate acidizing[R].SPE 96892,2005.
[24] AKANNI O O,NASR-EI-DIN H A.The accuracy of carbonate matrix-acidizing models in predicting optimum injection and wormhole propagation rates[R].SPE 172575,2015.
[25] ALMUTAIRI S,AL-OBIED M A,ALYAMI I,et al.Wormhole propagation in Tar during matrix acidizing of carbonate formations[R].SPE 151560,2012.
[26] TAN Xuehao,WENG Xiaowei,COHEN C E.An improved wormhole propagation model with a field example[R].SPE 179017,2016.
[27] GOLFIER F,BAZIN B,ZARCONE C,et al.Acidizing carbonate reservoirs:numerical modelling of wormhole propagation and comparison to experiments[R].SPE 68922,2001.

耦合双重分形蚓孔的表皮因子计算模型

Skin factor calculation model coupled with dual fractal wormhole

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	刘鹏, 王永诗, 宋明水, 刘雅利, 王敏, 张顺, 王彤达. 碳酸盐岩断裂带断层岩特征及演化——以渤海湾盆地济阳坳陷车镇凹陷下古生界为例[J]. 石油学报, 2021, 42(5): 588-597.
[2]	许林, 刘书杰, 许明标, 冯桓榰, 邢希金, 邓佳佳. 压差激活密封剂的微缺陷自适应修复行为及机理[J]. 石油学报, 2021, 42(5): 686-694.
[3]	张友, 李强, 郑兴平, 厉玉乐, 沈安江, 朱茂, 熊冉, 朱可丹, 王显东, 齐井顺, 张君龙, 邵冠铭, 佘敏, 宋叙, 孙海航. 塔里木盆地东部古城—肖塘地区寒武纪—奥陶纪台地类型、演化过程及有利储集相带[J]. 石油学报, 2021, 42(4): 447-465.
[4]	张世铭, 王建功, 张永庶, 张小军, 张婷静, 崔俊. 柴达木盆地西部地区下干柴沟组湖相白云岩晶间孔型储层物性下限的确定[J]. 石油学报, 2021, 42(1): 45-55,118.
[5]	吴小奇, 陈迎宾, 翟常博, 王彦青, 曾华盛, 刘文汇, 杨俊, 倪春华, 周凌方, 宋晓波. 川西坳陷中三叠统雷口坡组天然气气源对比[J]. 石油学报, 2020, 41(8): 918-927,1018.
[6]	王建功, 张永庶, 李翔, 徐丽, 石亚军, 黄叶秋, 王玉林, 管斌, 张世铭, 高妍芳. 柴达木盆地西部渐新统纹理石沉积特征与原位成藏[J]. 石油学报, 2020, 41(8): 940-959.
[7]	姚安林, 田晓建, 徐涛龙, 高山, 蒋宏业, 李又绿. 管道爆炸对同沟邻管的冲击效应及防爆墙抗爆性能[J]. 石油学报, 2020, 41(6): 753-761.
[8]	黄中伟, 张世昆, 李根生, 杨睿月, 武晓光, 张宏源, Kamy Sepehrnoori. 液氮磨料射流破碎高温花岗岩机理[J]. 石油学报, 2020, 41(5): 604-614.
[9]	刘宝增, 漆立新, 李宗杰, 刘军, 黄超, 杨林, 马灵伟, 龚伟. 顺北地区超深层断溶体储层空间雕刻及量化描述技术[J]. 石油学报, 2020, 41(4): 412-420.
[10]	程洪, 汪彦, 鲁新便. 塔河地区深层碳酸盐岩断溶体圈闭类型及特征[J]. 石油学报, 2020, 41(3): 301-309.
[11]	齐宁, 陈国彬, 李振亮, 梁冲, 何龙. 基于分步算法的裂缝性碳酸盐岩油藏大尺度酸化数值模拟[J]. 石油学报, 2020, 41(3): 348-362,371.
[12]	王宜林, 宋新民, 王贵海, 汪华, 李兆明, 张红, 聂臻. 中东地区油气合作区快速规模上产关键技术与实践[J]. 石油学报, 2020, 41(12): 1633-1642.
[13]	张彦廷, 郑志滨, 陈敬凯, 黄鲁蒙, 张晧, 王志坤, 葛政. 石油钻柱顶部高频激振解卡耦合响应特性[J]. 石油学报, 2020, 41(12): 1697-1705.
[14]	郭建春, 任冀川, 王世彬, 苟波, 赵俊生, 伍林. 裂缝性致密碳酸盐岩储层酸压多场耦合数值模拟与应用[J]. 石油学报, 2020, 41(10): 1219-1228.
[15]	徐加祥, 丁云宏, 杨立峰, 刘哲, 高睿, 王臻. 压裂支撑剂在迂曲微裂缝中输送与分布规律[J]. 石油学报, 2019, 40(8): 965-974.