基于损伤力学变内压条件下水泥环密封完整性模拟

doi:10.7623/syxb202011012

石油学报 ›› 2020, Vol. 41 ›› Issue (11): 1425-1433.DOI: 10.7623/syxb202011012

基于损伤力学变内压条件下水泥环密封完整性模拟

郭辛阳^1,2, 宋雨媛^1,2, 步玉环^1,2, 郭胜来^1,2, 柳华杰^1,2, 王成文^1,2

1. 中国石油大学(华东)非常规油气开发教育部重点实验室山东青岛 266580;
2. 中国石油大学(华东)石油工程学院山东青岛 266580

收稿日期:2020-01-30 修回日期:2020-07-28 出版日期:2020-11-25 发布日期:2020-12-11
通讯作者: 郭辛阳,男,1983年9月生,2006年获中国石油大学(华东)学士学位,2011年获中国石油大学(华东)博士学位,现为中国石油大学(华东)高级实验师、硕士生导师,主要从事固完井方面的科研与教学工作。Email:gdayang@163.com
作者简介:郭辛阳,男,1983年9月生,2006年获中国石油大学(华东)学士学位,2011年获中国石油大学(华东)博士学位,现为中国石油大学(华东)高级实验师、硕士生导师,主要从事固完井方面的科研与教学工作。Email:gdayang@163.com
基金资助:
国家自然科学基金项目（No.51704325，No.51704321）、教育部长江学者和创新团队发展计划项目（IRT_14R58）和中央高校基本科研业务费专项（18CX02103A）资助。

Simulation of seal integrity of cement sheath under variable internal casing pressure based on damage mechanics

Guo Xinyang^1,2, Song Yuyuan^1,2, Bu Yuhuan^1,2, Guo Shenglai^1,2, Liu Huajie^1,2, Wang Chengwen^1,2

1. MOE Key Laboratory of Unconventional Oil&Gas Development, China University of Petroleum, Shandong Qingdao 266580, China;
2. School of Petroleum Engineering, China University of Petroleum, Shandong Qingdao 266580, China

Received:2020-01-30 Revised:2020-07-28 Online:2020-11-25 Published:2020-12-11

摘要/Abstract

摘要：

针对变内压条件下水泥环密封完整性失效问题，基于连续损伤力学理论，采用同时考虑水泥石损伤和屈服后应力—应变关系的塑性损伤本构模型来描述实际水泥石的全应力—应变力学性能，研究了水泥石力学性能对密封完整性的影响。研究结果表明，向常规水泥浆中加入弹韧性材料形成弹韧性水泥，降低了水泥环弹性模量，既可以预防微间隙形成和减小微间隙尺寸，又可以预防和减少水泥环拉伸破坏。但并非弹性模量越低，弹韧性水泥密封完整性越好，密封完整性还与水泥环拉压弹性变形性能有关，同等情况下水泥环最大拉压弹性应变越大，其密封完整性越不容易失效。建议根据水泥环的弹性模量和拉压全应力—应变关系来评价水泥环密封完整性。研究结果为水泥环密封完整性评价和水泥石力学性能优化提供了一定依据。

关键词: 变内压, 水泥环, 密封完整性, 损伤, 塑性, 弹性模量

Abstract:

Aiming at the failure in the seal integrity of cement sheath under the variable internal casing pressure, based on the theory of continuous damage mechanics, this paper describes the complete stress-strain mechanical properties of actual set cement using the constitutive model of plastic damage that considers both set cement damage and the post-yield stress-strain relationship, and studies the effect of the mechanical properties of set cement on seal integrity. The results show that adding elastic-ductile materials into conventional cement slurry to form elastic-ductile cement will reduce the elastic modulus of cement sheath, which can prevent the formation of micro gap and reduce the size of micro gap, as well as prevent and reduce the tensile damage of cement sheath. However, it does not mean that the lower the elastic modulus, the better the seal integrity of elastic-ductile cement. The seal integrity is also related to the tensile and compressive elastic deformation performance of cement sheath. Under the same circumstances, the greater the maximum tensile and compressive elastic strain of cement sheath, the more impossible the failure in seal integrity. It is recommended to evaluate the seal integrity of cement sheath comprehensively based on its elastic modulus and the complete stress-strain relationship under tension and compression. The research results provide a basis for evaluating the seal integrity of cement sheath and optimizing the mechanical properties of set cement.

Key words: variable internal pressure, cement sheath, seal integrity, damage, plasticity, elastic modulus

中图分类号:

TE256

郭辛阳, 宋雨媛, 步玉环, 郭胜来, 柳华杰, 王成文. 基于损伤力学变内压条件下水泥环密封完整性模拟[J]. 石油学报, 2020, 41(11): 1425-1433.

Guo Xinyang, Song Yuyuan, Bu Yuhuan, Guo Shenglai, Liu Huajie, Wang Chengwen. Simulation of seal integrity of cement sheath under variable internal casing pressure based on damage mechanics[J]. Acta Petrolei Sinica, 2020, 41(11): 1425-1433.

参考文献

[1] 魏国齐,郑雅丽,邱小松,等. 中国地下储气库地质理论与应用[J].石油学报,2019,40(12):1519-1530.
WEI Guoqi,ZHENG Yali,QIU Xiaosong,et al.Geological theory and application of underground gas storage in China[J].Acta Petrolei Sinica,2019,40(12):1519-1530.
[2] 初纬,沈吉云,杨云飞,等.连续变化内压下套管-水泥环-围岩组合体微环隙计算[J].石油勘探与开发,2015,42(3):379-384.
CHU Wei,SHEN Jiyun,YANG Yunfei,et al.Calculation of micro-annulus size in casing-cement sheath-formation system under continuous internal casing pressure change[J].Petroleum Exploration and Development,2015,42(3):379-384.
[3] 王黎松,高宝奎,胡天祥,等.考虑材料非线性的环空增压预测模型[J].石油学报,2020,41(2):235-243.
WANG Lisong,GAO Baokui,HU Tianxiang,et al.A prediction model of annular pressure build-up considering material nonlinearity[J].Acta Petrolei Sinica,2020,41(2):235-243.
[4] 赵垒,闫怡飞,王鹏,等.气井生产过程中碳钢管柱CO₂腐蚀规律[J].石油学报,2019,40(2):232-239.
ZHAO Lei,YAN Yifei,WANG Peng,et al.CO₂ corrosion law of carbon steel tubing string in the production process of gas well[J].Acta Petrolei Sinica,2019,40(2):232-239.
[5] 杨振杰,姜晓强,吴志强,等.固井水泥环完整性模拟评价实验仪研究[J].钻井液与完井液,2013,30(6):9-12.
YANG Zhenjie,JIANG Xiaoqiang,WU Zhiqiang,et al.Research on simulation evaluation instrument of the integrity of cement sheath[J].Drilling Fluid & Completion Fluid,2013,30(6):9-12.
[6] 刘仍光,张林海,陶谦,等.循环应力作用下水泥环密封性实验研究[J].钻井液与完井液,2016,33(4):74-78.
LIU Rengguang,ZHANG Linhai,TAO Qian,et al.Experimental study on airtightness of cement sheath under alternating stress[J].Drilling Fluid & Completion Fluid,2016,33(4):74-78.
[7] 张万栋,李炎军,吴江,等.高温条件下的固井第一界面水力胶结强度实验研究[J].钻采工艺,2019,42(5):24-26.
ZHANG Wandong,LI Yanjun,WU Jiang,et al.Experimental study of hydraulic casing-cement bonding strength under high temperature conditions[J].Drilling & Production Technology,2019,42(5):24-26.
[8] 任韶然,韩波,任建峰,等.油藏埋存CO₂泄漏机制及故障树分析[J].中国石油大学学报:自然科学版,2017,41(1):96-101.
REN Shaoran,HAN Bo,REN Jianfeng,et al.Mechanisms and fault tree analysis of CO₂ leakage during geological storage in oil reservoirs[J].Journal of China University of Petroleum:Edition of Natural Science,2017,41(1):96-101.
[9] 赵效锋,管志川,史玉才,等.固井界面微环隙产生机制及计算方法[J].中国石油大学学报:自然科学版,2017,41(5):94-101.
ZHAO Xiaofeng,GUAN Zhichuan,SHI Yucai,et al.An assessment method for occurrence of micro-annular fractures on cementing interfaces of oil and gas well casing[J].Journal of China University of Petroleum:Edition of Natural Science,2017,41(5):94-101.
[10] 胡志强,杨进,路保平,等.深水泡沫套管静水压载特性与压力控制机理[J].石油学报,2019,40(6):726-733.
HU Zhiqiang,YANG Jin,LU Baoping,et al.Hydrostatic pressure characteristics and pressure control mechanism of foam casing in deepwater wells[J].Acta Petrolei Sinica,2019,40(6):726-733.
[11] 陶飞宇.非均匀地应力条件下水泥环失效特征研究[D].大庆:东北石油大学,2017.
TAO Feiyu.Study on failure characteristics of cement annulus under non-uniform stress[D].Daqing:Northeast Petroleum University,2017.
[12] 刘奎,王宴滨,高德利,等.页岩气水平井压裂对井筒完整性的影响[J].石油学报,2016,37(3):406-414.
LIU Kui,WANG Yanbin,GAO Deli,et al.Effects of hydraulic fracturing on horizontal wellbore for shale gas[J].Acta Petrolei Sinica,2016,37(3):406-414.
[13] 郭辛阳,吴涌泉,步玉环,等.变内压条件下井筒完整性的弹塑性分析[J].中国石油大学学报:自然科学版,2018,42(3):64-69.
GUO Xinyang,WU Yongquan,BU Yuhuan,et al.Elastoplastic analysis of wellbore integrity under varying internal casing pressure[J].Journal of China University of Petroleum:Edition of Natural Science,2018,42(3):64-69.
[14] 张广清.分支井筒稳定的塑性力学模型及分析[J].中国石油大学学报:自然科学版,2013,37(5):81-87.
ZHANG Guangqing.Plastic Mechanics Model for wellbore stability analysis of branched wells[J].Journal of China University of Petroleum:Edition of Natural Science,2013,37(5):81-87.
[15] 杜金龙,金衍,李坤朝,等.水泥石气密封性实验研究[J].石油科学通报,2018,3(3):313-319.
DU Jinlong,JIN Yan,LI Kunchao,et al.Experimental study of air sealing of cement[J].Petroleum Science Bulletin,2018,3(3):313-319.
[16] 王磊,曾义金,张青庆,等.高温环境下油井水泥石力学性能试验[J].中国石油大学学报:自然科学版,2018,42(6):88-95.
WANG Lei,ZENG Yijin,ZHANG Qingqing,et al.Experimental study on mechanical properties of oil well cement under high temperature[J].Journal of China University of Petroleum:Edition of Natural Science,2018,42(6):88-95.
[17] 雷拓,钱江,刘成清.混凝土损伤塑性模型应用研究[J].结构工程师,2008,24(2):22-27.
LEI Tuo,QIAN Jiang,LIU Chengqing.Application of damaged plasticity model for concrete[J].Structural Engineers,2008,24(2):22-27.
[18] 刘健.油气井水泥石力学行为本构方程与完整性评价模型研究[D].成都:西南石油大学,2013.
LIU Jian.Research on constitutive equations and evaluation models of mechanical integrity of cement stone[D].Chengdu:Southwest Petroleum University,2013.
[19] Dassault Systemes Simulia Corporation.Abaqus 6.14 Theory Guide[M].Providence:Dassault Systemes Simulia Corporation,2014.
[20] LUBLINER J,OLIVER J,OLLER S,et al.A plastic-damage model for concrete[J].International Journal of Solids and Structures, 1989,25(3):299-326.
[21] LEE J,FENVES G L.Plastic-damage model for cyclic loading of concrete structures[J].Journal of Engineering Mechanics,1998,124(8):892-900.
[22] BIRTEL V,MARK P.Parameterized finite element modeling of RC beam shear failure[C]//Proceedings of the 19th Annual International ABAQUS Users'Conference.Boston,USA:ABAQUS Company,2006.
[23] 祝效华,张智,常学军,等.复杂结构井磨损套管连接螺纹的三维力学行为[J].石油学报,2015,36(6):748-753.
ZHU Xiaohua,ZHANG Zhi,CHANG Xuejun,et al.Three-dimensional mechanical behavior of worn casing connecting thread in complex well[J].Acta Petrolei Sinica,2015,36(6):748-753.

基于损伤力学变内压条件下水泥环密封完整性模拟

Simulation of seal integrity of cement sheath under variable internal casing pressure based on damage mechanics

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张智, 王嘉伟, 吴优, 霍宏博, 谢涛, 李金蔓. 页岩气水平井固井水泥环状态对套管力学完整性的影响[J]. 石油学报, 2022, 43(8): 1158-1172.
[2]	鲁雪松, 柳少波, 田华, 马行陟, 于志超, 范俊佳, 桂丽黎, 刘强. 深层背斜圈闭中泥岩盖层完整性评价方法及其应用——以四川盆地川中地区震旦系气藏为例[J]. 石油学报, 2021, 42(4): 415-427.
[3]	朱华银, 王粟, 张敏, 武志德, 石磊. 盐穴储气库全周期注采模拟——以JT储气库X1和X2盐腔为例[J]. 石油学报, 2021, 42(3): 367-377.
[4]	李勇, 纪宏飞, 邢鹏举, 苏义脑, 刘硕琼, 魏风奇. 气井井筒温度场及温度应力场的理论解[J]. 石油学报, 2021, 42(1): 84-94.
[5]	蒲春生, 郑恒, 杨兆平, 高振东. 水平井分段体积压裂复杂裂缝形成机制研究现状与发展趋势[J]. 石油学报, 2020, 41(12): 1734-1743.
[6]	赵少伟, 马英文, 刘飞航, 李海涛, 张建丰. 基于线性强化弹塑性疏松砂岩破裂模式[J]. 石油学报, 2019, 40(S2): 131-140.
[7]	陈国明, 李家仪, 畅元江, 王康, 修梓翔, 刘浩林, 许亮斌, 盛磊祥. 深水油气水下井口系统疲劳损伤影响因素[J]. 石油学报, 2019, 40(S2): 141-151.
[8]	杨浩. 三轴地应力作用下固井二界面的稳定性[J]. 石油学报, 2019, 40(S2): 152-159.
[9]	祝效华, 孙汉文, 赵金洲, 张烈辉, 张爽. 天然气水合物沉积物等效变弹性模量损伤本构模型[J]. 石油学报, 2019, 40(9): 1085-1094.
[10]	畅元江, 王健, 李家仪, 聂振宇, 张伟国, 许亮斌, 刘秀全, 陈国明. 考虑温度影响的水下井口疲劳损伤计算方法[J]. 石油学报, 2019, 40(4): 482-492.
[11]	解宁, 李文婧. 地下盐穴储气库盐岩热损伤机理[J]. 石油学报, 2019, 40(3): 357-369,382.
[12]	吴千慧, 葛际江, 张贵才, 郭洪宾, 赵庆琛. 高强度堵水剂裂缝细管模型堵水模拟实验[J]. 石油学报, 2019, 40(11): 1368-1375.
[13]	杨兆中, 刘云锐, 张平, 李小刚, 易良平. 煤层气直井地层破裂压力计算模型[J]. 石油学报, 2018, 39(5): 578-586.
[14]	舒秋贵, 罗德明. 宾汉塑性流体中旋流扶正器间距设计方法[J]. 石油学报, 2017, 38(4): 461-467.
[15]	李勇, 陈瑶, 靳建洲, 江乐, 丁峰, 袁雄. 页岩气井体积压裂条件下的水泥环界面裂缝扩展[J]. 石油学报, 2017, 38(1): 105-111.