深水疏松砂岩储层微粒运移损害的控制方法

doi:10.7623/syxb202207012

石油学报 ›› 2022, Vol. 43 ›› Issue (7): 1016-1025.DOI: 10.7623/syxb202207012

深水疏松砂岩储层微粒运移损害的控制方法

邱正松^1,2, 高健³, 赵欣^1,2, 耿麒¹, 刘书杰⁴, 孙昊¹, 邢希金³

1. 中国石油大学(华东)石油工程学院山东青岛 266580;
2. 中国石油大学(华东)非常规油气开发教育部重点实验室山东青岛 266580;
3. 中海油研究总院有限责任公司北京 100027;
4. 中海石油(中国)有限公司海南分公司海南海口 570312

收稿日期:2021-04-27 修回日期:2022-02-17 出版日期:2022-07-25 发布日期:2022-08-01
通讯作者: 赵欣,男,1987年2月生,2015年获中国石油大学(华东)博士学位,现为中国石油大学(华东)副教授、硕士生导师,主要从事海洋深水钻井液完井液技术研究。Email:zhaoxin@upc.edu.cn
作者简介:邱正松,男,1964年8月生,2001年获石油大学(华东)博士学位,现为中国石油大学(华东)教授、博士生导师,主要从事钻井液完井液理论与技术研究。Email:qiuzs63@sina.com
基金资助:
国家重点基础研究发展计划（973）项目（2015CB251205）和国家自然科学基金项目（No.51804331、No.51974354）资助。

Control methods for fines migration damage in deepwater unconsolidated sandstone reservoirs

Qiu Zhengsong^1,2, Gao Jian³, Zhao Xin^1,2, Geng Qi¹, Liu Shujie⁴, Sun Hao¹, Xing Xijin³

1. School of Petroleum Engineering, China University of Petroleum, Shandong Qingdao 266580, China;
2. MOE Key Laboratory of Unconventional Oil and Gas Development, China University of Petroleum, Shandong Qingdao 266580, China;
3. CNOOC Research Institute Company Limited, Beijing 100027, China;
4. Hainan Branch, CNOOC China Limited, Hainan Haikou 570312, China

Received:2021-04-27 Revised:2022-02-17 Online:2022-07-25 Published:2022-08-01

摘要/Abstract

摘要： 中国南海深水疏松砂岩油气层钻完井作业中，易发生微粒运移、堵塞，造成储层损害，需要探索微粒运移损害的控制方法。选用南海深水疏松砂岩储层岩样，通过微粒吸附和释放实验以及岩心动态损害评价实验，探讨了纳米材料控制微粒运移损害的作用效果；实验分析了纳米颗粒吸附对岩石表面形貌、粗糙度及电性的影响；利用微粒与吸附纳米颗粒的岩石孔壁之间的相互作用能计算模型，分析了不同离子强度下储层微粒与岩石孔壁之间的总相互作用势能及作用机制。结果表明，纳米颗粒能有效控制深水储层微粒的运移，将其吸附并固定在孔壁表面。随着流体离子强度增加，控制运移的作用效果增强。其中，纳米氧化铝NP-1的作用效果最好，可明显提高深水储层岩心的渗透率恢复值，并且与深水钻井完井液具有良好的配伍性。模型计算结果表明，吸附纳米颗粒后，岩石孔壁与储层微粒之间的总相互作用势能下降，有利于岩石孔壁吸附、固定微粒，原因是纳米颗粒的吸附增加了岩石表面粗糙度及黏附力矩，也影响了表面电荷分布，有利于降低排斥势垒，并使初级势阱加深，提高岩石表面固定微粒的能力。因此，深水钻完井中，可通过加入纳米颗粒、适当提高工作液矿化度来减少微粒运移引起的储层损害。

关键词: 深水储层, 疏松砂岩, 微粒运移, 纳米颗粒, 储层损害, 相互作用势能, 矿化度

Abstract: In the drilling and completion operations of deepwater unconsolidated sandstone reservoirs in the South China Sea, fines migration and plugging are prone to occur, causing reservoir damage. Therefore, it is necessary to explore the ways of controlling damages during fines migration. Using rock samples from deepwater unconsolidated sandstone reservoirs in the South China Sea, the control effect of nanomaterials on fines migration damage was investigated by particle adsorption and release experiments and core dynamic damage evaluation experiments; the effects of nanoparticle adsorption on rock surface morphology, roughness and electrical properties were also analyzed; the interaction energy calculation model between particles and rock pore walls adsorbed with nanoparticles was used to analyze the total interaction energy between particles and rock pore surfaces under different ionic strengths and its action mechanism. The results show that nanoparticles can effectively control the migration of deep-water reservoir fines, which are adsorbed and fixed on the surface of pores. The control effect on migration increases with the increasing of fluid ion strength. Among them, the nano-alumina NP-1 has the best effect and can significantly increase the return permeability of deepwater reservoir cores and has good compatibility with deepwater drill-in fluid. Model calculations show that after adsorption of nanoparticles, the total interaction potential energy between rock pore surface and reservoir fines decreases, which is favorable to the adsorption and immobilization of particles on rock pore surface, because the adsorption of nanoparticles leads to an increase in rock surface roughness and adhesion moment, and also affects the surface charge distribution, which is beneficial to reducing the repulsion potential barrier, deepening the primary potential well, and improving the ability of rock surface to immobilize particles. Therefore, reservoir damage caused by fines migration can be reduced by adding nanoparticles and appropriately increasing the salinity of working fluid in deepwater drilling and completion.

Key words: deepwater reservoir, unconsolidated sandstone, fines migration, nanoparticles, formation damage, interaction potential energy, salinity

中图分类号:

TE258

邱正松, 高健, 赵欣, 耿麒, 刘书杰, 孙昊, 邢希金. 深水疏松砂岩储层微粒运移损害的控制方法[J]. 石油学报, 2022, 43(7): 1016-1025.

Qiu Zhengsong, Gao Jian, Zhao Xin, Geng Qi, Liu Shujie, Sun Hao, Xing Xijin. Control methods for fines migration damage in deepwater unconsolidated sandstone reservoirs[J]. Acta Petrolei Sinica, 2022, 43(7): 1016-1025.

参考文献

[1] 张功成, 屈红军, 张凤廉, 等.全球深水油气重大新发现及启示[J].石油学报, 2019, 40(1):1-34.
ZHANG Gongcheng, QU Hongjun, ZHANG Fenglian, et al.Major new discoveries of oil and gas in global deepwaters and enlightenment[J].Acta Petrolei Sinica, 2019, 40(1):1-34.
[2] 杨希冰, 周杰, 杨金海, 等.琼东南盆地深水区东区中生界潜山天然气来源及成藏模式[J].石油学报, 2021, 42(3):283-292.
YANG Xibing, ZHOU Jie, YANG Jinhai, et al.Natural gas source and accumulation model of Mesozoic buried hill in the eastern deep water area of Qiongdongnan Basin[J].Acta Petrolei Sinica, 2021, 42(3):283-292.
[3] 刘书杰, 谢仁军, 仝刚, 等.中国海洋石油集团有限公司深水钻完井技术进展及展望[J].石油学报, 2019, 40(S2):168-173.
LIU Shujie, XIE Renjun, TONG Gang, et al.Progress and prospect of deepwater well drilling and completion technique of CNOOC[J].Acta Petrolei Sinica, 2019, 40(S2):168-173.
[4] TAN Yunhui, LI Yan, RIJKEN M C M, et al.Modeling of production decline caused by fines migration in deepwater reservoirs[J].SPE Journal, 2020, 25(1):391-405.
[5] ZHAO Xin, QIU Zhengsong, SUN Baojiang, et al.Formation damage mechanisms associated with drilling and completion fluids for deepwater reservoirs[J].Journal of Petroleum Science and Engineering, 2019, 173:112-121.
[6] CIVAN F.Reservoir formation damage[M].3rd ed.U.S.:Gulf Professional Publishing, 2015.
[7] 尤启东, 陆先亮, 栾志安.疏松砂岩中微粒迁移问题的研究[J].石油勘探与开发, 2004, 31(6):104-107.
YOU Qidong, LU Xianliang, LUAN Zhi'an.Particle migration in loose sandstone reservoirs[J].Petroleum Exploration and Development, 2004, 31(6):104-107.
[8] BERA A, BELHAJ H.Application of nanotechnology by means of nanoparticles and nanodispersions in oil recovery-A comprehensive review[J].Journal of Natural Gas Science and Engineering, 2016, 34:1284-1309.
[9] SAZALI Y A, SAZALI W M L, IBRAHIM J M, et al.Investigation of fines migration for a high-pressure, high-temperature carbonate gas reservoir offshore Malaysia[J].Journal of Petroleum Exploration and Production Technology, 2020, 10(6):2387-2399.
[10] 王小聪, 雷群, 肖沛文, 等.现场水配制纳米驱油剂及其驱油机理[J].石油学报, 2021, 42(3):350-357.
WANG Xiaocong, LEI Qun, XIAO Peiwen, et al.Preparation of nano-oil-displacing agent with on-site water and its oil displacement mechanism[J].Acta Petrolei Sinica, 2021, 42(3):350-357.
[11] YUAN Bin, MOGHANLOO R G.Nanofluid precoating:an effective method to reduce fines migration in radial systems saturated with two mobile immiscible fluids[R].SPE 189464, 2018.
[12] JAFARBEIGI E, KAMARI E, SALIMI F, et al.Experimental study of the effects of a novel nanoparticle on enhanced oil recovery in carbonate porous media[J].Journal of Petroleum Science and Engineering, 2020, 195:107602.
[13] 魏兵, 陈神根, 赵金洲, 等.纳米纤维高稳泡沫在裂缝中的生成和运移规律[J].石油学报, 2020, 41(9):1135-1145.
WEI Bing, CHEN Shengen, ZHAO Jinzhou, et al.Formation and migration laws of nanofiber-based high-stability foam in fractures[J].Acta Petrolei Sinica, 2020, 41(9):1135-1145.
[14] 姜阿姣, 宋兆杰, 程婷婷, 等.纳米颗粒在岩石表面吸附-脱附规律研究[J].石油科学通报, 2020, 5(1):93-100.
JIANG Ajiao, SONG Zhaojie, CHENG Tingting, et al.Adsorption and desorption behavior of nanoparticles on rock surfaces[J].Petroleum Science Bulletin, 2020, 5(1):93-100.
[15] 张兴文, 庞雄奇, 李才俊, 等.深层-超深层高孔高渗碎屑岩油气藏地质特征、形成条件及成藏模式——以墨西哥湾盆地为例[J].石油学报, 2021, 42(4):466-480.
ZHANG Xingwen, PANG Xiongqi, LI Caijun, et al.Geological characteristics, formation conditions and accumulation model of deep and ultra-deep, high-porosity and high-permeability clastic reservoirs:a case study of Gulf of Mexico Basin[J].Acta Petrolei Sinica, 2021, 42(4):466-480.
[16] HUANG Tianping, CLARK D E.Enhancing oil recovery with specialized nanoparticles by controlling formation-fines migration at their sources in waterflooding reservoirs[R].SPE 166294, 2015.
[17] BELCHER C, SETH K, HOLLIER R, et al.Maximizing production life with the use of nanotechnology to prevent fines migration[R].SPE 132152, 2010.
[18] ARAB D, POURAFSHARY P.Nanoparticles-assisted surface charge modification of the porous medium to treat colloidal particles migration induced by low salinity water flooding[J].Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2013, 436:803-814.
[19] ZHAO Xin, QIU Zhengsong, GAO Jian, et al.Mechanism and effect of nanoparticles on controlling fines migration in unconsolidated sandstone formations[R].SPE 204474, 2021.
[20] 国家经济贸易委员会.钻井液完井液损害油层室内评价方法:SY/T 6540-2002[S].北京:石油工业出版社, 2002.
State Economic and Trade Commission.Lab testing method of drilling and completion fluids damaging oil formation:SY/T 6540-2002[S].Beijing:Petroleum Industry Press, 2002.
[21] 国家环境保护局.水质浊度的测定:GB 13200-1991[S].北京:中国标准出版社, 1992.
State Environmental Protection Administration.Water quality-determination of turbidity:GB 13200-1991[S].Beijing:Standards Press of China, 1992.
[22] BHATTACHARJEE S, CHEN J Y, ELIMELECH M.DLVO interaction energy between spheroidal particles and a flat surface[J].Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2000, 165(1/3):143-156.
[23] BHATTACHARJEE S, ELIMELECH M.Surface Element Integration:a novel technique for evaluation of DLVO interaction between a particle and a flat plate[J].Journal of Colloid and Interface Science, 1997, 193(2):273-285.
[24] BHATTACHARJEE S, KO C H, ELIMELECH M.DLVO interaction between rough surfaces[J].Langmuir, 1998, 14(12):3365-3375.
[25] HAMAKER H C.The London-van der Waals attraction between spherical particles[J].Physica, 1937, 4(10):1058-1072.
[26] OLIVEIRA R.Understanding adhesion:a means for preventing fouling[J].Experimental Thermal and Fluid Science, 1997, 14(4):316-322.
[27] HOGG R, HEALY T W, FUERSTENAU D W.Mutual coagulation of colloidal dispersions[J].Transactions of the Faraday Society, 1966, 62(62):1638-1651.

深水疏松砂岩储层微粒运移损害的控制方法

Control methods for fines migration damage in deepwater unconsolidated sandstone reservoirs

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王强, 赵金洲, 胡永全, 赵超能, 张祯祥. 岩心尺度静态自发渗吸的数值模拟[J]. 石油学报, 2022, 43(6): 860-870.
[2]	赵少伟, 马英文, 刘飞航, 李海涛, 张建丰. 基于线性强化弹塑性疏松砂岩破裂模式[J]. 石油学报, 2019, 40(S2): 131-140.
[3]	康毅力, 王凯成, 许成元, 游利军, 王立民, 李宁, 李家学. 深井超深井钻井堵漏材料高温老化性能评价[J]. 石油学报, 2019, 40(2): 215-223.
[4]	何延龙, 蒲春生, 景成, 谷潇雨, 刘洪志, 崔淑霞, 李晓, 宋俊强. 基于Hoshen-Kopelman算法的三维多孔介质模型中黏土矿物的构建[J]. 石油学报, 2016, 37(8): 1037-1046.
[5]	文江波, 张劲军, 郑飞, 陆争光. 流动条件下原油乳化含水率与水相组成的关系[J]. 石油学报, 2015, 36(5): 626-632.
[6]	邓金根　李　萍　周建良　何保生　陈胜宏　王利华. 中国海上疏松砂岩适度出砂井防砂方式优选[J]. 石油学报, 2012, 33(4): 676-680.
[7]	李大奇康毅力刘修善曾义金杜春朝. 基于漏失机理的碳酸盐岩地层漏失压力模型[J]. 石油学报, 2011, 32(5): 900-904.
[8]	刘向君梁利喜杨林曾祥林曹砚峰龙瀛刘洪. 分支井构型对疏松砂岩油藏临界生产压差的影响[J]. 石油学报, 2011, 32(4): 717-721.
[9]	雷登生杜志敏单高军李涧松朱炬辉陈建阳. 考虑变质量流水平井筒稠油携砂能力研究[J]. 石油学报, 2011, 32(1): 127-130.
[10]	王运所许化政王传刚贾斌峰. 鄂尔多斯盆地上古生界地层水分布与矿化度特征[J]. 石油学报, 2010, 31(5): 748-753.
[11]	王建华, 鄢捷年, 郑曼, 冯杰, 冯光斌. 钻井液固相和滤液侵入储层深度的预测模型[J]. 石油学报, 2009, 30(6): 923-926.
[12]	叶艳, 鄢捷年, 邹盛礼, 李再钧, 王书琪. 碳酸盐岩裂缝性储层钻井液损害评价新方法[J]. 石油学报, 2008, 29(5): 752-756.
[13]	李海涛, 王永清, 谭灿. 砂岩储层清水和污水混注对储层损害的实验评价[J]. 石油学报, 2007, 28(2): 137-139,143.
[14]	王克文, 孙建孟, 关继腾, 苏远大. 储层岩石电性特征的逾渗网络模型[J]. 石油学报, 2007, 28(1): 101-106.
[15]	王江萍, 张宁生. 油气储层损害识别及诊断信息融合模型研究[J]. 石油学报, 2006, 27(6): 107-111.